Recalls for 2004 Ford Escape

There are currently 8 recalls for your car.


What Should You Do?

Bring your car to a dealer immediately. Recalls are issued because the defect might make the car unsafe in some way. Your nearby service center can help verify if the repairs can be performed free of charge.

Contact a Service Center

NHTSA Vehicle Safety Recalls


Recall Number: 14V165000

Recall Date: 04/02/2014

Component: STRUCTURE:FRAME AND MEMBERS

Problem Summary: FORD MOTOR COMPANY (FORD) IS RECALLING CERTAIN MODEL YEAR 2001-2004 ESCAPE VEHICLES MANUFACTURED OCTOBER 22, 1999, THROUGH JANUARY 23, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA. THESE VEHICLES MAY EXPERIENCE EXCESSIVE CORROSION AT THE FORWARD ATTACHMENT OF THE LOWER CONTROL ARM.

Consequence: A SEPARATION OF THE LOWER CONTROL ARM CAN RESULT IN A SIGNIFICANT LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.

What Owners Should Do: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL A NEWLY DESIGNED REINFORCEMENT CROSS-BRACE, FREE OF CHARGE. PARTS ARE NOT CURRENTLY AVAILABLE. FORD EXPECTS TO SEND AN INTERIM NOTIFICATION AROUND MAY 19, 2014. WHEN PARTS ARE AVAILABLE, OWNERS WILL BE MAILED A SECOND LETTER TO COME IN TO HAVE THE PART INSTALLED. IF CUSTOMERS BRING THEIR VEHICLES TO A DEALER BEFORE REINFORCEMENT CROSSBRACES ARE AVAILABLE, DEALERS WILL INSPECT THE SUBFRAME AND EITHER INFORM CUSTOMERS THAT THE VEHICLE IS SAFE TO DRIVE UNTIL THE REMEDY PARTS ARE AVAILABLE OR PROVIDE A RENTAL VEHICLE UNTIL PARTS ARE AVAILABLE IF AN IMMEDIATE REPAIR IS NEEDED. OWNERS MAY CONTACT FORD AT 1-800-392-3673. FORD'S NUMBER FOR THIS RECALL IS 14S02.

Recall Number: 12V353000

Recall Date: 07/26/2012

Component: VEHICLE SPEED CONTROL:CABLES

Problem Summary: FORD MOTOR COMPANY IS RECALLING CERTAIN MODEL YEAR 2001 THROUGH 2004 ESCAPE VEHICLES EQUIPPED WITH 3.0L V6 ENGINES AND SPEED CONTROL MANUFACTURED FROM OCTOBER 22, 1999, THROUGH JANUARY 23, 2004. INADEQUATE CLEARANCE BETWEEN THE ENGINE COVER AND THE SPEED CONTROL CABLE CONNECTOR COULD RESULT IN A STUCK THROTTLE WHEN THE ACCELERATOR PEDAL IS FULLY OR ALMOST-FULLY DEPRESSED. THIS RISK EXISTS REGARDLESS OF WHETHER OR NOT SPEED CONTROL (CRUISE CONTROL) IS USED.

Consequence: A STUCK THROTTLE MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP OR SLOW THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

What Owners Should Do: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES BY INCREASING THE ENGINE COVER CLEARANCE, FREE OF CHARGE. THE SAFETY RECALL BEGAN AUGUST 3, 2012. REMEDY PARTS ARE EXPECTED TO BE AVAILABLE IN MID-AUGUST 2012. UNTIL THEN DEALERS WILL DISCONNECT THE SPEED CONTROL CABLE AS AN INTERIM REMEDY, IF PARTS ARE NOT AVAILABLE AT THE TIME OF AN OWNER'S SERVICE APPOINTMENT. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

Recall Number: 12V353000

Recall Date: 07/26/2012

Component: ENGINE AND ENGINE COOLING

Problem Summary: FORD MOTOR COMPANY IS RECALLING CERTAIN MODEL YEAR 2001 THROUGH 2004 ESCAPE VEHICLES EQUIPPED WITH 3.0L V6 ENGINES AND SPEED CONTROL MANUFACTURED FROM OCTOBER 22, 1999, THROUGH JANUARY 23, 2004. INADEQUATE CLEARANCE BETWEEN THE ENGINE COVER AND THE SPEED CONTROL CABLE CONNECTOR COULD RESULT IN A STUCK THROTTLE WHEN THE ACCELERATOR PEDAL IS FULLY OR ALMOST-FULLY DEPRESSED. THIS RISK EXISTS REGARDLESS OF WHETHER OR NOT SPEED CONTROL (CRUISE CONTROL) IS USED.

Consequence: A STUCK THROTTLE MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP OR SLOW THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

What Owners Should Do: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES BY INCREASING THE ENGINE COVER CLEARANCE, FREE OF CHARGE. THE SAFETY RECALL BEGAN AUGUST 3, 2012. REMEDY PARTS ARE EXPECTED TO BE AVAILABLE IN MID-AUGUST 2012. UNTIL THEN DEALERS WILL DISCONNECT THE SPEED CONTROL CABLE AS AN INTERIM REMEDY, IF PARTS ARE NOT AVAILABLE AT THE TIME OF AN OWNER'S SERVICE APPOINTMENT. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

Recall Number: 07V156000

Recall Date: 04/10/2007

Component: SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE

Problem Summary: ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.

Consequence: AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.

What Owners Should Do: DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Recall Number: 07E023000

Recall Date: 03/29/2007

Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Problem Summary: CERTAIN CARDONE MASTER CYLINDERS WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Consequence: LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

What Owners Should Do: CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

Recall Number: 06E064000

Recall Date: 07/17/2006

Component: EXTERIOR LIGHTING

Problem Summary: CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

What Owners Should Do: TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Recall Number: 04V602000

Recall Date: 12/20/2004

Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Problem Summary: CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.

Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.

What Owners Should Do: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Recall Number: 04V574000

Recall Date: 12/07/2004

Component: VEHICLE SPEED CONTROL:CABLES

Problem Summary: ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.

Consequence: AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.

What Owners Should Do: DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.

Certified Service Centers
Near Ashburn, VA

Certification requires warranty on parts and labor, fair-price* guarantee, certified technicians and high customer satisfaction ratings.

*Fair prices, measured by comparing them to the RepairPal Price Estimator.

Additional terms and conditions apply

2356 Heller Dr Dayton, OH 45434
888-283-6701
Service Pricing
550 1st St NW Cleveland, TN 37311
855-601-2824
Service Pricing
460 E Auto Center Dr Mesa, AZ 85210
877-259-5016
Service Pricing
See More Results