Recalls for 1999 Pontiac Montana

There are currently 7 recalls for your car.


What Should You Do?

Bring your car to a dealer immediately. Recalls are issued because the defect might make the car unsafe in some way. Your nearby service center can help verify if the repairs can be performed free of charge.

Contact a Service Center

NHTSA Vehicle Safety Recalls


Recall Number: 09E005000

Recall Date: 02/17/2009

Component: STEERING

Problem Summary: DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONSTM" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.

Consequence: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.

What Owners Should Do: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 20, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.

Recall Number: 07E021000

Recall Date: 03/12/2007

Component: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

Problem Summary: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Consequence: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

What Owners Should Do: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Recall Number: 04V597000

Recall Date: 12/22/2004

Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Problem Summary: ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.

What Owners Should Do: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.

Recall Number: 02V027000

Recall Date: 01/25/2002

Component: AIR BAGS:FRONTAL

Problem Summary: ON CERTAIN PASSENGER VEHICLES AND MINI VANS, THE DRIVER'S AIR BAG INFLATOR MODULES COULD PRODUCE EXCESSIVE INTERNAL PRESSURE. IN THE EVENT OF A CRASH THAT WOULD TRIGGER A DRIVER'S AIR BAG DEPLOYMENT, THE INCREASED INTERNAL PRESSURE CAN CAUSE THE INFLATOR MODULE TO EXPLODE.

Consequence: METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.

What Owners Should Do: DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN FEBRUARY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PONTIAC AT 1-800-762-2737.

Recall Number: 01V264000

Recall Date: 08/21/2001

Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Problem Summary: VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.

Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

What Owners Should Do: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

Recall Number: 01V067000

Recall Date: 03/08/2001

Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Problem Summary: VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.

Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

What Owners Should Do: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

Recall Number: 99V071000

Recall Date: 04/12/1999

Component: STEERING:GEAR BOX:SHAFT SECTOR

Problem Summary: VEHICLE DESCRIPTION: PASSENGER MINI VANS. THE LEFT AND/OR RIGHT FRONT LOWER INSULATOR TO CRADLE CENTER METAL SLEEVE IS COLLAPSED, WHICH CAN RESULT IN LOSS OF CLAMP LOAD IN THE JOINT. IF THE CLAMP LOAD IS REDUCED OR LOST, THE BOLT CAN BE LOST OR BROKEN AND THE JOINT CAN SEPARATE.

Consequence: IF NOT REPAIRED, SEPARATION OF THE OPPOSITE SIDE JOINT COULD OCCUR RESULTING IN STEERING SHAFT SEPARATION.

What Owners Should Do: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CRADLE-TO-SUSPENSION INSULATORS AND THE ATTACHING BOLTS.

Certified Service Centers
Near Ashburn, VA

Certification requires warranty on parts and labor, fair-price* guarantee, certified technicians and high customer satisfaction ratings.

*Fair prices, measured by comparing them to the RepairPal Price Estimator.

Additional terms and conditions apply