Recalls for 2005 Volkswagen Passat

There are currently 4 recalls for your car.


What Should You Do?

Bring your car to a dealer immediately. Recalls are issued because the defect might make the car unsafe in some way. Your nearby service center can help verify if the repairs can be performed free of charge.

Contact a Service Center

NHTSA Vehicle Safety Recalls


Recall Number: 14E007000

Recall Date: 03/07/2014

Component: ENGINE AND ENGINE COOLING:ENGINE

Problem Summary: THE GATES CORPORATION (GATES) IS RECALLING CERTAIN AFTERMARKET TRU-FLOW WATER PUMPS, PART NUMBER TFW 41127, MANUFACTURED AUGUST 2013 THROUGH OCTOBER 2013 THAT HAVE A SILVER-COLORED PULLEY/SPROCKET OR DO NOT HAVE 'US9377' STAMPED ON THE WATER PUMP HOUSING. THESE SERVICE REPLACEMENT PARTS WERE SOLD FOR USE IN MODEL YEAR 1999-2005 AUDI A4, 2000-2006 AUDI TT, 1998-2005 VOLKSWAGEN BEETLE, 1999-2006 GOLF, 1999-2008 AND 2011-2013 VOLKSWAGEN JETTA, AND 2000-2005 VOLKSWAGEN PASSAT. IN THE AFFECTED WATER PUMPS, THE PULLEY OR SPROCKET THAT TURNS THE TIMING BELT MAY DEVELOP MICROFRACTURES CAUSING THE TIMING BELT TO FAIL.

Consequence: A FAILURE OF THE TIMING BELT MAY CAUSE THE ENGINE TO SHUT DOWN, INCREASING THE RISK OF A VEHICLE CRASH.

What Owners Should Do: GATES WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE WATER PUMP, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON MAY 5, 2014. OWNERS MAY CONTACT THE GATES CORPORATION AT 1-303-744-1911.

Recall Number: 08V156000

Recall Date: 04/07/2008

Component: FUEL SYSTEM, GASOLINE:DELIVERY

Problem Summary: VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.

Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.

What Owners Should Do: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Recall Number: 07V063000

Recall Date: 02/20/2007

Component: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

Problem Summary: ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.

Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.

What Owners Should Do: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Recall Number: 04V586000

Recall Date: 12/15/2004

Component: FUEL SYSTEM, DIESEL

Problem Summary: ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.

What Owners Should Do: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.

Certified Service Centers
Near Ashburn, VA

Certification requires warranty on parts and labor, fair-price* guarantee, certified technicians and high customer satisfaction ratings.

*Fair prices, measured by comparing them to the RepairPal Price Estimator.

Additional terms and conditions apply

1550 Mansell Rd Alpharetta, GA 30009
866-906-2569
Service Pricing
4545 E 96th St Indianapolis, IN 46240
866-794-7655
Service Pricing
175 w jackson pago pago, IL 60604
888-697-4066
Service Pricing
See More Results