2004 Ford F-350 Recalls

There are currently 5 recalls for your vehicle. Change vehicle

Search by VIN

Get the status of recalls on your car.

Search By:

Enter all letters and numbers

Enter a valid 5-digit ZIP code.

NHTSA Vehicle Safety Recalls

  • Recall Number
    05V270000
    Recall Date
    06/10/2005
    Component
    ELECTRICAL SYSTEM:WIRING
    Summary

    CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.

    Consequence

    SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.

    What Owners Should Do

    DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

  • Recall Number
    04V229000
    Recall Date
    05/17/2004
    Component
    TIRES
    Summary

    CERTAIN LARIAT AND KING RANCH MODEL PICKUP TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." SOME TRUCKS WERE INADVERTENTLY EQUIPPED WITH AN INCORRECT LOAD RANGE TIRE. THIS WOULD RESULT IN INCORRECT TIRE LOAD RATINGS FOR THE STATED VEHICLE AXLE GROSS AXLE WEIGHT RATING. ALSO, THE TIRE MAY BE INFLATED ABOVE THE DOT LISTED INFLATION PRESSURE.

    Consequence

    IF A TIRE WAS OPERATED IN AN OVER-LOADED OR OVER-INFLATED CONDITION, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH CAN CAUSE A CRASH WITHOUT WARNING.

    What Owners Should Do

    DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE ANY INCORRECT LOAD RANGE TIRES. ADDITIONALLY, IF ANY TIRE REQUIRED REPLACEMENT, IT IS RECOMMENDED THAT THE WHEEL LUG NUT TORQUE BE CHECKED WITHIN 500 MILES AFTER ANY TIRE REPLACEMENT. OWNER NOTIFICATION BEGAN ON MAY 21, 2004. OWNERS SHOULD CONTACT. FORD AT 1-800-392-3673.

  • Recall Number
    11V352000
    Recall Date
    07/13/2011
    Component
    EXTERIOR LIGHTING:BRAKE LIGHTS
    Summary

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

    Consequence

    NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

    What Owners Should Do

    DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

  • Recall Number
    07E066000
    Recall Date
    08/28/2007
    Component
    EQUIPMENT:ELECTRICAL
    Summary

    CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

    Consequence

    IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

    What Owners Should Do

    ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

  • Recall Number
    07E106000
    Recall Date
    12/17/2007
    Component
    WHEELS:CAP/COVER/HUB
    Summary

    CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.

    Consequence

    WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.

    What Owners Should Do

    FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.

What Should You Do?

Contact your dealer as soon as possible
Every recall is serious, so it’s important that you contact an authorized service center as soon as possible to make an appointment to get it fixed.

Interested in learning more? Check out our Maintenance 101 tips or the terms glossary.

How Would You Review This Vehicle?

Consumer Review Rating

4.0

Average based on 14 reviews

Write a Review

Research the 2004 Ford F-350