Hyundai SANTA FE Recalls
Search for recalls by car
Make selection is required
NHTSA safety recall results (45)
Recall information provided by National Highway Traffic Safety Administration
Trailer hitches
2008-01-31
08E016000
HYUNDAI IS RECALLING 3,387 TRAILER HITCH WIRING HARNESSES EITHER INCLUDED WITH A TRAILER HITCH OR SOLD AS A SERVICE PART MANUFACTURED BY THULE TOWING SYSTEMS AND DISTRIBUTED BY HYUNDAI FOR INSTALLATION ON MY 2007-2008 SANTA FE AND VERACRUZ VEHICLES. THE ACCESSORY TRAILER HITCH WIRING HARNESS CONVERTER MODULE IS MOUNTED TO THE TOP SURFACE OF THE REAR BUMPER REINFORCEMENT. HIGH CURRENT LEAKAGE OR A SHORT CIRCUIT OF CAPACITOR C1 COULD CAUSE HEAT RELATED DAMAGE TO THE WIRING HARNESS CONVERTER MODULE.
EXCESSIVE HEAT MAY CAUSE DAMAGE TO THE REAR BUMPER AREA AND MAY POTENTIALLY RESULT IN A FIRE.
HYUNDAI WILL NOTIFY OWNERS AND WILL REPLACE THE TRAILER HITCH WIRING HARNESS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
View details Hide details
Air bags: Frontal
2005-11-16
05V527000
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN OCCUPANT CLASSIFICATION SYSTEM (OCS) THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY CERTAIN SMALL CHILDREN SEATED ON THE FRONT EDGE OF THE SEAT AS AN ADULT.
THE POSSIBILITY OF MISCLASSIFICATION OF CERTAIN SMALL CHILDREN AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG TO DEPLOY IN A FRONTAL COLLISION CRASH OR THE SIDE IMPACT AIRBAG TO DEPLOY IN A SIDE COLLISION CRASH; SEVERE INJURY OR DEATH COULD OCCUR.
DEALERS WILL ENSURE THAT THE VEHICLE'S OCS WILL PROPERLY CLASSIFY CERTAIN SMALL CHILDREN WHEN SEATED ON THE FRONT EDGE OF THE SEAT AND WILL DISABLE THE RIGHT FRONT AIRBAGS. DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT TO PROVIDE AN INCREASED MARGIN FOR RECOGNITION OF CERTAIN SMALL CHILDREN. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 6, 2005. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.
View details Hide details
Air bags
2005-09-30
05V450000
ON CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG FEATURE, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT SEAT. IF THERE HAS NOT BEEN A 'KEY ON' ' KEY OFF' CYCLE WITH THE RIGHT FRONT PASSENGER SEAT EMPTY PRIOR TO INSTALLATION OF THE CRS.
THE POSSIBILITY OF MISCLASSIFICATION OF A CRS AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG OR SIDE IMPACT AIRBAG TO DEPLOY IN A CRASH AND COULD RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.
DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2005. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
View details Hide details
Service brakes, hydraulic: Antilock: Control unit/module
2004-03-09
04V131000
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.5 LITER V-6 ENGINES, 4-WHEEL DRIVE AND ANTILOCK BRAKING SYSTEMS (ABS), IF THE BRAKE PEDAL IS DEPRESSED AT SPEEDS BETWEEN 3 AND 12 MPH WHEN THE BRAKE PAD FRICTION SURFACES ARE WET, A VIBRATION MAY OCCUR BETWEEN THE BRAKE DISCS AND PADS CAUSING ABS SENSOR ELECTRONIC SIGNAL NOISE TO DEVELOP. AT SPEEDS BELOW 5 MPH, THE ABS SENSOR SIGNAL NOISE MAY CAUSE THE ABS ELECTRONIC CONTROL UNIT (ECU) TO ACTIVATE THE ABS, EXTENDING THE STOPPING DISTANCE.
IF AN EXTENDED STOPPING DISTANCE OCCURS, IT COULD RESULT IN A CRASH.
DEALERS WILL REPROGRAM THE ABS ECU. OWNER NOTIFICATION BEGAN ON MARCH 24, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
View details Hide details
Equipment: Other: Labels
2003-11-04
03V520000
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS".
THE TIRE PRESSURE LABELS DO NOT CONTAIN THE INFORMATION REQUIRED BY THE STANDARD.
OWNERS WILL BE PROVIDED WITH A CORRECT LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON OCTOBER 29, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.