Chevrolet Monte Carlo Recalls
Search for recalls by car
Make selection is required
NHTSA safety recall results (9)
Recall information provided by National Highway Traffic Safety Administration
Component not known
00V228003
Certain passenger vehicles, light duty pickup trucks, sport utility vehicles, and mini vans equipped with TRW seat belt buckle assemblies fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 209, "Seat Belt Assemblies." The buckle base of these seat belt assemblies were not properly heat treated and do not pass the load bearing requirement of the standard. In the event of a vehicle crash, the occupant may not be properly restrained.
Dealers will inspect the vehicle's rear safety belt buckle assembly date codes and, if necessary, will replace any rear safety belt buckle assembly. The manufacturer has reported that owner notification was to begin during September 2000. Owners who do not receive the free remedy within a reasonable time should contact Buick at 1-800-521-7300; Chevrolet at 1-800-222-1020; GMC at 1-800-462- 782, Oldsmobile at 1-800-442-6537; Pontiac at 1-800-762-2737; or Saturn at 1-800-553-6000.
View details Hide details
Component not known
00V244
On certain passenger vehicles, the air bag sensing and diagnostic modules (SDM) could experience a memory error resulting in the air bags not deploying in a crash situation. In a crash, a front seat occupant may receive more serious injuries.
Dealers will replace the sensing and diagnostic module. The manufacturer has reported that owner notification was to begin during September 2000. Owners who do not receive the free remedy within a reasonable time should contact Chevrolet at 1-800-222-1020.
View details Hide details
Component not known
02V222
Certain passenger cars, minivans, and sport utility vehicles have an air bag inflator on the driver's side that could fracture at a weld during a deployment. Pieces of the inflator could strike and injure vehicle occupants, and the air bag cushion would not inflate fully, reducing the capability of the bag to protect the driver.
Dealers will inspect and replace, if necessary, the air bag module assembly on the driver's side. The manufacturer reported that owner notification was expected to begin during September 2002. Owners who do not receive the free remedy within a reasonable time should contact Buick at 1-800-521-7300, Cadillac at 1-800-458-8006, Chevrolet at 1-800-222-1020, GMC at 1-800-462-8782, Oldsmobile at 1-800-442-6537, or Pontiac at 1-800-762-2737.
View details Hide details
Component not known
03V250
Certain minivans, passenger cars, and sport utility vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 225, "Child Restraint Anchorage System." The owner's manual does not explain the meaning of the location symbols for the lower universal anchorage system.
Owners will be provided with a supplement for their owner's manual. It describes and shows the location symbols for the child restraint anchors that are located in the vehicle. The manufacturer has reported that owner notification is expected to begin during August 2003. Owners may contact Buick at 1-866-608-8080, Cadillac at 1-866-982-2339, Chevrolet at 1-800-630-2438, GMC at 1-800-996-9463, Pontiac at 1-800-620-7668, or Oldsmobile at 1-800-630-6537.
View details Hide details
Component not known
04V287
Certain passenger vehicles were produced with lower than specified torque on both front brake calipers to steering knuckle attachment bolts. With improper torque, the clamp load at the joint may not be adequate to prevent movement between the caliper bracket and knuckle. Depending on whether one or both bolts backs out or fractures, the result can be locking of the affected wheel during braking and an abrupt steering input in the direction of the locked wheel, reduced braking and noise from the affected wheel, or severing of a brake hose, increased brake pedal travel, and reduced steering control. Reduced braking or steering control could cause a crash.
Dealers are to tighten both bolts to the specified torque. The manufacturer has reported that owner notification began on July 6, 2004. Owners may contact Chevrolet at 1-800-630-2438 or Pontiac at 1-800-620-7668.
View details Hide details
Engine and engine cooling
2015-10-26
15V701000
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. GM is finalizing an improved remedy. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number, once the improved remedy has been finalized. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
View details Hide details
Electrical system
2014-07-03
14V400000
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 6,729,742 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2005 Chevrolet Malibu, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will provide two replacement key rings and key cover on all ignition keys, free of charge. The manufacturer has not yet provided a notification schedule. GM's number for this recall is 14350.
View details Hide details
Electrical system
2014-06-23
14V355000
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) is recalling certain model year 2005-2009 Buick LaCrosse, 2006-2011 Buick Lucerne, 2000-2005 Cadillac DeVille, 2006-2011 Cadillac DTS, 2006-2014 Chevrolet Impala, and 2006-2007 Chevrolet Monte Carlo vehicles. In the affected vehicles, the weight on the key ring and road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. Additionally, a key knocked out of the run position could cause loss of engine power, power steering, and power braking, increasing the risk of a vehicle crash.
GM will notify owners, and dealers will install two 13mm key rings and key insert into the vehicle's ignition keys, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), and 1-800-222-1020 (Chevrolet). GM's number for this recall is 14299.
View details Hide details
Steering
2009-02-11
09E005000
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONSTM " BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 20, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.