2003 Chevrolet Express 1500 Recalls
Search for recalls by car
Make selection is required
NHTSA safety recall results (6)
Recall information provided by National Highway Traffic Safety Administration
Component not known
02V305
Some of these vans were built without a wheel bearing assembly retaining nut, which could lead to a possible bearing separation. If this were to occur, the ABS system would be disabled. The driver would also notice a grinding noise, a decrease in the vehicle speed, and the steering will pull in the direction of the affected brake assembly. This could result in a loss of vehicle control, increasing the risk of a crash.
Dealers will inspect the wheel bearing assembly. If the inspection reveals a missing retaining nut, the wheel bearing assembly will be replaced. The manufacturer has reported that owner notification began Nov. 13, 2002. Owners should contact Chevrolet at 1-800-222-1020 or GMC at 1-800-462-8782.
View details Hide details
Component not known
03V050
On certain vans with a gross vehicle weight of less than 8,500 pounds, during a crash sufficient to deploy the safety belt pretensioner, the front safety belt buckles may not release after a crash, or may cause the buckle to unlatch in a crash, resulting in an increased risk of personal injury.
Dealers will replace the front driver and passenger side safety belt buckle. The manufacturer has reported that owner notification is expected to begin during April 2003. Owners may contact Chevrolet at 1-800-222-1020, or GMC at 1-800-462-8782.
View details Hide details
Component not known
03V217
Certain passenger vans have a condition in which water may enter and corrode the rear license plate lamp socket. If the lamp socket were to corrode, the rear license plate lamp may operate intermittently or not at all, and the left rear tail lamp may become inoperative. The temperature of the license plate lamp socket could increase to the point that it may begin to soften and melt. Eventually, the plastic could ignite and a fire could occur.
Dealers will install a new sealed rear license plate lamp socket assembly. The manufacturer has reported that owner notification is expected to begin during July 2003. Owners may contact Chevrolet at 1-8000-222-1020 or GMC at 1-800-462-8782.
View details Hide details
Component not known
03V250
Certain minivans, passenger cars, and sport utility vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 225, "Child Restraint Anchorage System." The owner's manual does not explain the meaning of the location symbols for the lower universal anchorage system.
Owners will be provided with a supplement for their owner's manual. It describes and shows the location symbols for the child restraint anchors that are located in the vehicle. The manufacturer has reported that owner notification is expected to begin during August 2003. Owners may contact Buick at 1-866-608-8080, Cadillac at 1-866-982-2339, Chevrolet at 1-800-630-2438, GMC at 1-800-996-9463, Pontiac at 1-800-620-7668, or Oldsmobile at 1-800-630-6537.
View details Hide details
Component not known
04V045
Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 135, "Passenger Car Brake Systems." Some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore. Consequently, the valve O-ring seal may fracture. Steering efforts may be slightly increased while braking or parking. Under certain driving conditions, a fractured seal may also require an increase in the applied brake pedal effort to achieve the same vehicle deceleration.
Dealers are to replace the hydro-boost relief valve. The manufacturer has reported that owner notification is expected to begin during the second quarter of 2004. Owners may contact Cadillac at 1-866-982-2339; Chevrolet at 1-800-630-2438; GMC at 1-866-996-9463; or Hummer at 1-866-486-6376.
View details Hide details
Structure
2003-03-07
03V094000
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.