Ford Ranger Recalls
Search for recalls by car
Make selection is required
NHTSA safety recall results (45)
Recall information provided by National Highway Traffic Safety Administration
Fuel system, gasoline: Delivery: Hoses, lines/piping, and fittings
2011-02-21
11V126000
FORD IS RECALLING CERTAIN MODEL YEAR 2010 FORD RANGER TRUCKS MANUFACTURED FROM OCTOBER 15, 2009, THROUGH MAY19, 2010. THE ENGINE FUEL LINE IN THE AREA OF THE THROTTLE BODY SHIELD MAY NOT HAVE A PROTECTIVE CONVOLUTE (COVER) PROPERLY INSTALLED. IF THE PROTECTIVE CONVOLUTE ON THE FUEL LINE IS NOT ASSEMBLED IN THE PROPER POSITION, THE EDGE OF THE SHIELD MAY CONTACT THE FUEL LINE. OVER TIME THIS CONTACT MAY CHAFE THE FUEL LINE, RESULTING IN A FUEL ODOR AND A POTENTIAL FUEL LEAK.
A SUFFICIENT FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
DEALERS WILL TRIM THE THROTTLE BODY SHIELD AWAY FROM THE FUEL LINE AND INSPECT THE FUEL LINE FOR WEAR, AND REPLACE THE LINE IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 7, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
View details Hide details
Parking brake: Driveline: Hydraulic: Actuator
2010-05-06
10V202000
FORD IS RECALLING CERTAIN MODEL YEAR 2010 RANGER VEHICLES MANUFACTURED FROM JUNE 8, 2009 THROUGH FEBRUARY 2, 2010 EQUIPPED WITH MANUAL TRANSMISSION. IT IS POSSIBLE FOR THE PARKING BRAKE CABLE TO BECOME DISCONNECTED FROM THE RIGHT REAR ACTUATOR DURING COLD WEATHER. THIS MAY OCCUR WHEN THE PARKING BRAKE IS RELEASED IF WET PARKING BRAKE SHOES HAVE FROZEN IN THE APPLIED POSITION. IF THE RIGHT REAR PARKING BRAKE CABLE BECOMES DISCONNECTED, THE PEDAL WILL HAVE EXTENDED TRAVEL AND MAY NOT FULLY APPLY THE PARKING BRAKE.
A MANUAL TRANSMISSION VEHICLE PARKED IN NEUTRAL WITHOUT A FULLY APPLIED PARKING BRAKE MAY HAVE UNINTENDED MOVEMENT WHICH MAY CAUSE A CRASH.
DEALERS WILL INSTALL A REVISED RIGHT REAR PARKING BRAKE ACTUATOR TO PREVENT CABLE DISCONNECTION FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE MAY 19, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
View details Hide details
Suspension: Multiple axle
2009-01-16
09V040000
FORD IS RECALLING 11,134 MY 2009 4X2 RANGER VEHICLES. SOME FRONT WHEEL SPINDLES WERE IMPROPERLY MANUFACTURED CREATING THE RISK THAT A SPINDLE MAY FRACTURE DURING THE NORMAL USEFUL LIFE OF THE TRUCK.
IF A SPINDLE FRACTURES, THE WHEEL MAY SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE FRONT SPINDLE IF NECESSARY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2009. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
View details Hide details
Visibility
2005-11-09
05V520000
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
View details Hide details
Structure: frame and members: Underbody shields
2004-07-12
04V331000
ON CERTAIN PICKUP TRUCKS, THE FRAME MAY HAVE A CENTER RAIL SECTION FLANGE THAT WAS NOT FORMED PROPERLY.
IN THE EVENT OF A SIDE IMPACT CRASH, THE FRAME RAIL SCOULD PUNCTURE THE FUEL TANK, RESULTING IN A FUEL LEAK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
DEALERS WILL INSPECT THE FRAME TO DETERMINE WHETHER THE FRAME WAS INCORRECTLY MANUFACTURED. IF THERE IS A PROBLEM, THE VEHICLE WILL NOT BE REPAIRED. FORD AND THE DEALER WILL REPLACE THE VEHICLE. THE RECALL BEGAN ON JULY 19, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.