Isuzu Recalls
Search for recalls by car
Make selection is required
NHTSA safety recall results (29)
Recall information provided by National Highway Traffic Safety Administration
Power train, structure
2017-02-17
17V105000
Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain 2015-2017 NPR HD, NPR XD, NQR and NRR trucks. During manufacturing, the stamping equipment may have created burrs on the frame crossmember that the transmission is mounted to. These burrs may cause the transmission mounting studs to break.
If the studs break, the transmission may not be properly supported, preventing it from shifting correctly and increasing the risk of a crash.
Isuzu will notify owners, and dealers will inspect the vehicles and install a metal shim to prevent stress on the mounting studs, free of charge. The recall is expected to begin April 2017. Owners may contact Isuzu customer service at 1-866-441-9638.
View details Hide details
Vehicle speed control
2016-11-02
16V797000
Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain model year 2014-2016 Isuzu NPR and NPR HD vehicles manufactured August 26, 2013, to November 11, 2016, and 2016 Chevrolet Low Cab Forward 3500 and 4500 vehicles manufactured July 27, 2016, to November 11, 2016. The affected vehicles have a throttle pedal that may get stuck under the steel stopper bolt, causing the pedal to remain in the full throttle position. Isuzu Technical Center of America, Inc. (Isuzu) is recalling certain model year 2014-2016 Isuzu NPR and NPR HD vehicles manufactured August 26, 2013, to November 11, 2016, and 2016 Chevrolet Low Cab Forward 3500 and 4500 vehicles manufactured July 27, 2016, to November 11, 2016. The affected vehicles have a throttle pedal that may get stuck under the steel stopper bolt, causing the pedal to remain in the full throttle position. Note: In gasoline models only.
A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.
Isuzu will notify owners, and dealers will remove and replace the stopper bolt with a flanged plate, to prevent lateral movement of the throttle, free of charge. The recall began November 14, 2016. Owners may contact Isuzu customer service at 1-866-441-9638.
View details Hide details
Exterior lighting
2014-11-18
14V735000
Isuzu Manufacturing Services of America (Isuzu) is recalling certain model year 2012-2014 Reach chassis manufactured July 26, 2011, to August 7, 2014. In the affected vehicles, the brake light switch may be bent while braking, possibly causing it to not activate the brake lights and potentially corrode.
If the brake light switch bends or corrodes, the brake light switch may become inoperative, increasing the risk of a crash.
Isuzu will notify owners, and dealers will apply a protector and a waterproof cover with an extension harness so that the switch cannot be bent or corroded, free of charge. Parts are not currently available. Owners will be sent an interim notification and then will be sent a second notice when remedy parts are available. Isuzu issued an interim notification to owners on December 17, 2014. The manufacturer has not yet provided a notification schedule. Owners may contact Isuzu customer service at 1-866-441-9638.
View details Hide details
Component not known
2014-07-02
14V404000
General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.
A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available. GM will send an interim letter to owners in late August 2014. A second owner letter will be mailed when parts are available. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), 1-800-462-8782 (GMC), 1-800-955-9007 (SAAB), and 1-800-255-6727 (Isuzu). GM's number for this recall is 14309. NOTE: This recall provides a new remedy for all vehicles covered by recall 13V-248. Vehicles whose modules were modified but not replaced as part of the previous recall remedy must have their vehicles remedied again under this campaign.
View details Hide details
Component not known
2014-04-17
14V203000
Isuzu Manufacturing Services of America, Inc. (Isuzu) is recalling certain model year 2012-2013 Reach stripped chassis manufactured July 26, 2011, through August 27, 2013. The horn switch contacts may be bent or may wear prematurely causing the horn not to work.
An inoperable horn may increase the risk of a crash.
Isuzu will notify owners, and dealers will inspect the horn contact shaft to see if it is bent or if it has premature wear, and replace the steering wheel combination switch if either condition is found, free of charge. The recall is expected to begin in May 2014. Owners may contact Isuzu customer service at 1-866-441-9638. Isuzu's number for this recall is CB14-N-001.
View details Hide details
Suspension
2013-10-31
13V547000
Isuzu Manufacturing Services of America, Inc (Isuzu) is recalling certain model year 2003-2004 Rodeo and Axiom, and 2003 Rodeo Sport vehicles that were originally sold in, or are currently registered in, Maine, New Hampshire, Vermont, Massachusetts, Rhode Island, Connecticut, New York, New Jersey, Pennsylvania, Delaware, Maryland, the District of Columbia, West Virginia, Ohio, Indiana, Michigan, Illinois, Wisconsin, Minnesota, Iowa, Kentucky and Missouri. These vehicles may experience excessive corrosion near the forward mounting point bracket for the left or right rear suspension lower link.
The corrosion may allow the bracket to detach from the frame, impacting vehicle handling and increasing the risk of a crash.
Isuzu will notify owners, and dealers will inspect the rear suspension lower link bracket area. For vehicles in which little or no corrosion is found, the area will be treated with an anti-corrosive compound. For vehicles in which corrosion has damaged the rear suspension lower link bracket and affected its connection to the vehicle frame, a reinforcement bracket will be installed. In the event the corrosion is so severe that the reinforcement bracket remedy would not be sufficient, Isuzu will offer to repurchase the vehicle for an amount based on the Kelley Blue Book "Private Party" price. All inspections and remedies will be provided free of charge for vehicles that are 10 years old or less. For vehicles older than 10 years, Isuzu will offer a free remedy, but only if the vehicle is presented to an Isuzu service facility dealer within 12 months of when owner notifications were issued, after that time owners will be charged for the repairs. The recall is expected to begin in mid-De...
View details Hide details
Power train
2013-05-16
13V206000
Isuzu Manufacturing Services of America, Inc. (Isuzu) is recalling certain model year 2013 N-Series trucks manufactured March 8, 2012, through Auguest 2, 2012 and equipped with an automatic transmission. Due to a manufacturing change, the transmission retaining ring may dislodge from the clutch drum.
If the ring dislodges while the vehicle is in motion, the vehicle may lose forward driving power and become stalled, increasing the risk of a crash.
Isuzu will notify owners, and dealers will replace the affected transmissions, free of charge. The recall began on June 28, 2013. Customers may contact Isuzu Customer service at 1-866-441-9638.
View details Hide details
Vehicle speed control
2011-08-15
11V415000
ISUZU IS RECALLING CERTAIN MODEL YEAR 2012 N-SERIES TRUCKS EQUIPPED WITH GASOLINE ENGINES, MANUFACTURED FROM APRIL 27, 2011, THROUGH JULY 26, 2011. DUE TO A CALIBRATION ERROR IN THE ECM SOFTWARE, IN THE EVENT OF A FAILURE OR MALFUNCTION OF THE BRAKE PEDAL SWITCH, APPLICATION OF THE BRAKE PEDAL WILL NOT CAUSE THE CRUISE CONTROL TO BE CANCELED.
THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
ISUZU WILL NOTIFY OWNERS, AND DEALERS WILL REPROGRAM THE ECM SOFTWARE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN LATE AUGUST OR EARLY SEPTEMBER 2011. OWNERS MAY CONTACT ISUZU AT 1-734-455-7595.
View details Hide details
Service brakes, air: Supply: Compressor
2009-07-28
09V309000
GM IS RECALLING 1,880 MODEL YEAR 2007 CHEVROLET KODIAK, T-SERIES, GMC TOPKICK, T-SERIES AND ISUZU F-SERIES AND H-SERIES PASSENGER VEHICLES EQUIPPED WITH 7.8L DIESEL ENGINE. THE AIR COMPRESSOR IN SOME OF THESE VEHICLES MAY NOT BUILD ENOUGH AIR PRESSURE TO SUPPORT THE AIR BRAKE SYSTEM. IF THIS CONDITION WERE TO OCCUR WHILE THE VEHICLES WAS STATIONARY (BRAKES APPLIED), THE AIR BRAKES WOULD REMAIN APPLIED AND PREVENT THE VEHICLE FROM MOVING.
IF THE DRIVER IGNORES THESE WARNINGS AND CONTINUES TO DRIVE THE VEHICLE, AND IF THERE WAS A CONTINUED LOSS OF PRESSURE, THE REAR SPRING PARKING BRAKES WOULD AUTOMATICALLY APPLY, PREVENTING THE TRUCK FROM BEING DRIVEN.
DEALERS WILL INSPECT THE AIR COMPRESSOR FOR ITS ABILITY TO BUILD AIR PRESSURE, AND EITHER MODIFY THE AIR COMPRESSOR BY ELIMINATION OF THE SUPPRESSION VALVE OR REPLACE THE AIR COMPRESSOR ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
View details Hide details
Exterior lighting: Brake lights: Switch
2009-07-28
09V310000
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY FEBRUARY 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.