Saturn Ion Recalls

Make selection is required

NHTSA safety recall results (9)

Recall information provided by National Highway Traffic Safety Administration

Electrical system

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Recall consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Recall action: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The manufacturer has not yet provided a notification schedule. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," o...

Steering

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Recall consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Recall action: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from O...

Electrical system

General Motors LLC (GM) announced on February 10, 2014 that they are recalling certain model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. Two weeks later, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Recall consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Recall action: GM will notify owners, and dealers will replace the ignition switch, free of charge. The recall began on March 10, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring.

Exterior lighting

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Recall consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Recall action: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Exterior lighting: Turn signal

CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.

Recall consequence: IF A FRONT TURN SIGNAL LAMP IS INOPERATIVE, OTHERS MAY REACT MORE SLOWLY TO A TURNING VEHICLE AND A CRASH COULD OCCUR.
Recall action: DEALERS WILL REPLACE THE DRL/TURN SIGNAL BULB ON BOTH THE LEFT AND RIGHT FRONT SIDE AND INSPECT FOR AND ADD A DRL JUMPER KIT IF NOT PRESENT. THE RECALL BEGAN NOVEMBER 17, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.

Fuel system, other: Delivery: Fuel pump

CERTAIN VEHICLES EQUIPPED WITH SUPERCHARGED 2.0L 4-CYLINDER (LSJ) ENGINE WERE BUILT WITH A FUEL FEED PIPE THAT COULD CRACK AND LEAK FUEL NEAR THE FUEL RAIL. IF FUEL LEAKS FROM THE FUEL FEED PIPE, THERE WOULD BE A NOTICEABLE FUEL ODOR AROUND THE VEHICLE.

Recall consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Recall action: DEALERS WILL REPLACE THE FUEL FEED PIPE ASSEMBLY. OWNER NOTIFICATION BEGAN ON JUNE 9, 2004. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.

Structure: Body: Bumpers

ON CERTAIN PASSENGER VEHICLES, SOME WELDS BETWEEN THE PASSENGER'S SIDE MOTOR RAIL AND THE FRONT BUMPER BRACKET DO NOT MEET ENGINEERING SPECIFICATIONS.

Recall consequence: LONG TERM DURABILITY OF THE JOINT MAY BE REDUCED AND SEPARATION OF THE BUMPER FROM THE FRAME ON THE PASSENGER'S SIDE OF THE VEHICLE MAY RESULT, INCREASING THE RISK OF A CRASH.
Recall action: ALL VEHICLES ARE STILL IN DEALER'S POSSESSIONS.

Visibility: Power window devices and controls

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, 'POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS.' THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION AND THE FRONT PASSENGER DOOR IS OPENED.

Recall consequence: IF UNSUPERVISED CHILDREN ARE LEFT UNATTENDED IN THE VEHICLE AND OPERATE THE POWER WINDOWS OR SUNROOF, THERE IS AN INCREASED RISK OF INJURY TO THE CHILD.
Recall action: DEALERS WILL UPGRADE THE BODY CONTROL MODULE (BCM) CALIBRATION. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.

Fuel system, gasoline

CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.

Recall consequence: IF CORROSION ON THE EXTERIOR SURFACE OF THE FUEL FILTER PROGRESSES TO THE POINT OF CREATING A HOLE IN THE SHELL, FUEL DROPLETS COULD FORM AND DROP TO THE GROUND. IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Recall action: DEALERS WILL REPLACE THE FUEL FILTER ASSEMBLY. OWNER NOTIFICATION BEGAN ON DECEMBER 30, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-972-8876.