Volkswagen Jetta Recalls

Make selection is required

NHTSA safety recall results (53)

Recall information provided by National Highway Traffic Safety Administration

Suspension

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2011-2013 Jetta vehicles manufactured March 1, 2010, to November 30, 2012, and 2012-2013 Beetle vehicles manufactured March 1, 2011, to July 31, 2013. The durability of the rear trailing arms may be reduced in vehicles whose rear trailing arms have been previously deformed, such as a result of a rear or side-rear impact crash.

Recall consequence: The reduced durability of the trailing arm may result in its sudden fracture, possibly causing loss of vehicle control and increasing the risk of a crash.
Recall action: Volkswagen will notify owners, and dealers will install a sheet metal inlay on the rear axle trailing arms designed to prevent a sudden loss of control in the event of trailing arm sudden fracture, free of charge. Owners will be mailed an interim notification in November 2014 and will be mailed a second letter when remedy parts are available. Owners may contact Volkswagen customer service at 1-800-893-5298.

Power train: Automatic transmission: Cooling unit and lines

Volkswagen of America, Inc. (Volkswagen) is recalling certain model year 2014 Jetta, Beetle, Beetle Convertible, and Passat vehicles equipped with a 1.8T engine and torque converter automatic transmission. In the affected vehicles, the O-ring seals between the oil cooler and the transmission may leak fluid.

Recall consequence: The leaking transmission fluid could contact a hot surface and result in a vehicle fire.
Recall action: Volkswagen will notify owners, and dealers will replace the O-ring seals in the transmission oil cooler, free of charge. The recall is expected to begin on April 16, 2014. Owners may contact Volkswagen at 1-800-822-8987. Volkswagen's number for this recall is 38B9/9V.

Power train

Volkswagen Group of America, Inc (Volkswagen) is recalling certain model year 2013-2014 Jetta Hybrid vehicles manufactured October 2012 through October 2013 and equipped with a DQ-200 direct-shift gearbox. Due to gearbox fluid additives, the control module within the gearbox may corrode. The deposits from this corrosion may cause an electrical short and result in a stall-like condition.

Recall consequence: This sudden loss of power while driving increases the risk of a crash.
Recall action: Volkswagen will notify owners, and dealers will replace the gearbox oil with a non-corrosive version, free of charge. The recall began on December 6, 2013. Owners may contact Volkswagen at 1-800-893-5298. Volkswagen's recall number is 34F6/4V.

Fuel system, diesel

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Recall consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.
Recall action: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Engine and engine cooling: Exhaust system

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2011-2012 JETTA SEDAN VEHICLES MANUFACTURED FROM MARCH 18, 2010, THROUGH AUGUST 22, 2011. SOME VEHICLES HAD A STAINLESS STEEL EXHAUST TIP INSTALLED AT THE PORT DURING IMPORTATION. THESE EXHAUST TIPS MAY EXTEND BEYOND THE ORIGINAL LENGTH OF THE FACTORY-INSTALLED EXHAUST PIPES. IT IS POSSIBLE FOR INADVERTENT CONTACT TO OCCUR WITH A PERSON'S LEG.

Recall consequence: IF THE TAILPIPE EXTENSION IS HOT DURING INADVERTENT CONTACT, A BURN COULD OCCUR.
Recall action: DEALERS WILL INSPECT AND REPLACE THE STAINLESS STEEL EXHAUST TIPS AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Engine and engine cooling: Exhaust system

VOLKSWAGEN IS RECALLING CERTAIN STAINLESS STEEL EXHAUST TIPS, PART NUMBER 1K0 071 910 U, SOLD AS ACCESSORY EQUIPMENT FOR USE ON MODEL YEAR 2011-2012 JETTA SEDAN VEHICLES MANUFACTURED FROM MARCH 18, 2010, THROUGH AUGUST 22, 2011. THESE EXHAUST TIPS MAY EXTEND BEYOND THE ORIGINAL LENGTH OF THE FACTORY-INSTALLED EXHAUST PIPES. IT IS POSSIBLE FOR INADVERTENT CONTACT TO OCCUR WITH A PERSON'S LEG.

Recall consequence: IF THE TAILPIPE EXTENSION IS HOT DURING INADVERTENT CONTACT, A BURN COULD OCCUR.
Recall action: DEALERS WILL INSPECT AND REPLACE THE STAINLESS STEEL EXHAUST TIPS AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Electrical system: Fuses and circuit breakers

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2011 JETTA VEHICLES, MANUFACTURED FROM MARCH 2010 THROUGH MARCH 2011. THESE VEHICLES MAY HAVE AN ELECTRICAL WIRING AND FUSE LAYOUT WHERE THE CONVERTER BOX IS PROTECTED BY THE SAME FUSE USED BY THE SIGNAL HORN AND THE ANTI-THEFT ALARM SYSTEM. SHOULD THAT FUSE BE BLOWN, THE CONVERTER BOX WILL BE DISCONNECTED FROM THE POWER SUPPLY WHICH, IN TURN, WILL SHUT OFF APPLICATIONS SUCH AS THE ENGINE MANAGEMENT SYSTEM, LIGHTING SYSTEM, AND WIPERS.

Recall consequence: SHOULD THIS HAPPEN WHILE THE VEHICLE IS BEING DRIVEN, THE ENGINE COULD STALL, OR THE HEADLIGHTS OR WIPERS COULD TURN OFF UNEXPECTEDLY, POTENTIALLY LEADING TO A CRASH WITHOUT WARNING.
Recall action: VOLKSWAGEN WILL NOTIFY OWNERS WHEN SUFFICIENT QUANTITIES OF REPAIRS KITS ARE AVAILABLE. DEALERS WILL SEPARATE THE WIRING FOR THE HORN AND THE THEFT PROTECTION HORN FROM THE POWER SUPPLY OF THE CONVERTER BOX AND ROUTE THE WIRES TO SEPARATE FUSES TO CORRECT THE CONDITION FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987

Fuel system, gasoline: Delivery: Hoses, lines/piping, and fittings

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Recall consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Recall action: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Power train: Automatic transmission

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Recall consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.
Recall action: VOLKSWAGEN WILL NOTIFY OWNERS, INSPECT THE DSG AND, IF NECESSARY, REPLACE AN AFFECTED DSG TEMPERATURE SENSOR FREE OF CHARGE. THE MANUFACTURER HAS NOT YET PROVIDED A NOTIFICATION SCHEDULE. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Power train: Driveline: Driveshaft

VOLKSWAGEN IS RECALLING 25,594 MY 2006-2009 JETTA 5TH GENERATION EQUIPPED WITH 2.01 ENGINE. THE FASTENING SCREW CONTACT SURFACES ON THE DRIVESHAFT COVER PLATE MAY NOT HAVE BEEN MANUFACTURED TO FACTORY SPECIFICATIONS. SOME SCREWS MAY NOT HAVE BEEN TORQUED PROPERLY DURING ASSEMBLY AND COULD LOOSEN OVER TIME, CAUSING A KNOCKING SOUND WHEN THE VEHICLE IS IN MOTION. THE DRIVESHAFT SCREWS COULD LOOSEN TO THE POINT WHERE THE DRIVESHAFT DETACHES FROM THE GEARBOX.

Recall consequence: IF THE VEHICLE IS MOVING WHEN THIS HAPPENS, THE DETACHED DRIVESHAFT COULD CAUSE DAMAGE THE GEARBOX HOUSING. A DAMAGE GEARBOX HOUSING COULD LEAK GEARBOX OIL ONTO THE STREET AND CREATE A RISK OF A VEHICLE CRASH FOR BOTH THE DRIVER AND OTHER MOTORISTS.
Recall action: DEALERS WILL INSPECT THE DRIVESHAFT SCREWS AND REPLACE THE SCREWS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JUNE 19, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.