Volkswagen Recalls

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2011 JETTA VEHICLES, MANUFACTURED FROM MARCH 2010 THROUGH MARCH 2011. THESE VEHICLES MAY HAVE AN ELECTRICAL WIRING AND FUSE LAYOUT WHERE THE CONVERTER BOX IS PROTECTED BY THE SAME FUSE USED BY THE SIGNAL HORN AND THE ANTI-THEFT ALARM SYSTEM. SHOULD THAT FUSE BE BLOWN, THE CONVERTER BOX WILL BE DISCONNECTED FROM THE POWER SUPPLY WHICH, IN TURN, WILL SHUT OFF APPLICATIONS SUCH AS THE ENGINE MANAGEMENT SYSTEM, LIGHTING SYSTEM, AND WIPERS.

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2010 ROUTAN VEHICLES MANUFACTURED FROM OCTOBER 2009 THROUGH JUNE 2010. SOME VEHICLES MAY EXPERIENCE INADVERTENT IGNITION KEY DISPLACEMENT FROM THE RUN TO ACCESSORY POSITION WHILE DRIVING CAUSING THE ENGINE TO SHUT OFF.

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2010 NEW BEETLE AND NEW BEETLE CONVERTIBLE MANUFACTURED FROM SEPTEMBER 1, 2010, THROUGH SEPTEMBER 22, 2010, FOR FAILING TO COMPLY WITH THE BARRIER TEST REQUIREMENTS OF FEDERAL MOTOR VEHICLES SAFETY STANDARDS NO. 208, "OCCUPANT CRASH PROTECTION," THAT WENT INTO EFFECT ON SEPTEMBER 1, 2010.

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 ROUTAN VEHICLES MANUFACTURED FROM JUNE 2008 THROUGH JULY 2009. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION. CONTACT WITH A 12V POWER FEED CIRCUIT WITHIN THE HARNESS MAY CAUSE A HIGH RESISTIVE SHORT CIRCUIT WITHIN THE LATCH MECHANISM LOCATED INSIDE OF THE SLIDING DOOR.

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

VOLKSWAGEN IS RECALLING 14,416 MY 2007-2009 TOUAREG VEHICLES. THE FASTENING STRUTS ON THE ROOF EDGE SPOILER CAN CRACK, CAUSING THE SPOILER TO BECOME LOOSE AND POSSIBLY DETACH FROM THE VEHICLE WITHOUT WARNING, EVEN THOUGH INITIALLY THE SPOILER MAY FEEL SECURE.

VOLKSWAGEN IS RECALLING 25,594 MY 2006-2009 JETTA 5TH GENERATION EQUIPPED WITH 2.01 ENGINE. THE FASTENING SCREW CONTACT SURFACES ON THE DRIVESHAFT COVER PLATE MAY NOT HAVE BEEN MANUFACTURED TO FACTORY SPECIFICATIONS. SOME SCREWS MAY NOT HAVE BEEN TORQUED PROPERLY DURING ASSEMBLY AND COULD LOOSEN OVER TIME, CAUSING A KNOCKING SOUND WHEN THE VEHICLE IS IN MOTION. THE DRIVESHAFT SCREWS COULD LOOSEN TO THE POINT WHERE THE DRIVESHAFT DETACHES FROM THE GEARBOX.

VOLKSWAGEN IS RECALLING 5,000 MY 2008 R32 (5TH GENERATION) VEHICLES. WHEN CERTAIN DRIVING CONDITIONS ARE ACCOMPANIED BY HIGH AMBIENT TEMPERATURES, THE FUEL TANK VENTILATION VALVE MAY NOT REMAIN FULLY CLOSED. IF THIS HAPPENS, LIQUID FUEL MAY ENTER THE FUEL TANK VENTING SYSTEM AND MIGRATE INTO THE EVAPORATIVE SYSTEM, SATURATING THE CARBON CANISTER. SHOULD THIS OCCUR WHILE DRIVING, THE VEHICLE MAY EXPERIENCE PERFORMANCE ISSUES (I.E., VEHICLE JERKING) AND THE MALFUNCTION INDICATOR LAMP (MIL) IN THE INSTRUMENT CLUSTER COULD ILLUMINATE. FUEL COULD LEAK FROM THE EVAPORATIVE SYSTEM LEAK DETECTION PUMP FILTER.

VOLKSWAGEN IS RECALLING 5,750 MY 2009 CC VEHICLES. SOME AFFECTED VEHICLES MAY HAVE AN INCORRECTLY ROUTED RIGHT FRONT PASSENGER SEAT BELT BUCKLE WIRING HARNESS, CREATING THE POTENTIAL FOR WIRES TO BECOME DAMAGED WHEN THE SEAT IS MOVED FULLY UP OR DOWN OR FORE AND AFT. IF THIS WIRING DAMAGE OCCURS, THE AIRBAG CONTROL MODULE WILL SWITCH TO A FALLBACK ALGORITHM AND DEACTIVATE THE PASSENGER'S FRONTAL AIR BAG. VEHICLE OCCUPANTS WILL BE MADE AWARE OF THIS AIRBAG DEACTIVATION WHEN BOTH THE AIRBAG WARNING LIGHT IN THE INSTRUMENT CLUSTER AND THE PASSENGER AIRBAG "OFF" LAMP ILLUMINATE.