Chevrolet Silverado 3500 Recalls
Search for recalls by car
Make selection is required
NHTSA safety recall results (76)
Recall information provided by National Highway Traffic Safety Administration
Component not known
00V404
On some of these vehicles, either or both of the two body pressure relief valves (PRV) may not seal and could become inoperative during the life of the vehicle if the body installed on the vehicle does not protect the PRV from road debris. If a PRV does not seal, exhaust fumes could enter into the passenger cab and could cause possible illness, unconsciousness, or death.
Dealers will inspect the vehicle to ensure that the PRVs are protected by the body of the vehicle. If the PRVs are not protected by the body, the dealer will install new shielded PRVs. The manufacturer has reported that owner notification was to begin during January 2001. Owners who do not receive the free remedy within a reasonable time should contact Chevrolet at 1-800-222-1020 or GMC at 1-800-462-6537.
View details Hide details
Latches/locks/linkages
2024-11-26
24V894000
General Motors, LLC (GM) is recalling certain 2024 Chevrolet Silverado HD 2500, 3500, and GMC Sierra HD 2500, 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in Park.
An unlatched tailgate may open and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.
Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed December 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N242469160. This recall is an expansion of NHTSA Recall 24V-060.
View details Hide details
Power train
2024-10-24
24V797000
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Rear wheel lock-up can increase the risk of a crash.
Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters are expected to be mailed December 9, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.
View details Hide details
Air bags
2024-10-10
24V756000
General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2018-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 Crew Cab trucks. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.
A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC Customer Service at 888-988-7267. GM's number for this recall is N242474500.
View details Hide details
Latches/locks/linkages
2024-02-01
24V060000
General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.
An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.
Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters are expected to be mailed March 18, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232426400.
View details Hide details
Steering
2023-08-03
23V549000
General Motors, LLC (GM) is recalling certain 2024 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles. The steering gear shaft may fracture and disconnect from the steering arm.
A steering arm that disconnects may result in a total loss of steering control, increasing the risk of a crash.
Dealers will inspect and replace the steering gear, if necessary, free of charge. Owner notification letters are expected to be mailed September 18, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232414720.
View details Hide details
Fuel system, diesel
2023-02-02
23V047000
General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles equipped with a dual fuel tank option. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.
An engine stall increases the risk of a crash.
Dealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. Owner notification letters are expected to be mailed March 24, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N222368030.
View details Hide details
Service brakes, hydraulic
2021-09-29
21V758000
General Motors, LLC (GM) is recalling certain 2021-2022 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 vehicles with electronic brake control modules (EBCM) replaced during vehicle assembly. The bolts that attach the brake pressure modulator valve (BPMV) assembly may not be properly tightened, which could fail to seal the two sub-assemblies and allow water intrusion.
Water in the BPMV may cause an electrical short circuit and increase the risk of fire.
Owners are advised to park outside and away from other structures until the recall repair is completed. Dealers will replace the BPMV assembly, free of charge. Owner notification letters are expected to be mailed November 15, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N212349181.
View details Hide details
Exterior lighting
2021-08-17
21V643000
Swab Wagon Company, Inc. (Swab Wagon) is recalling certain 2017 Chevrolet 2500 HD, 2018-2019 Chevrolet 3500 HD, and 2019 Ford F-350 Swab Pioneer medic vehicles equipped with Code 3 7x9 Stop-Tail-Turn Reverse All-in-One LED lights. The lights may be too bright, exceeding the maximum light output allowed which may adversely affect the vision of drivers. As such, these lamps fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
The excessive brightness may affect the vision of other drivers, increasing the risk of a crash.
Swab Wagon will provide instructions on how to obtain a filter kit from the light manufacturer, free of charge. Owner notification letters were mailed on August 26, 2021. Owners may contact Swab Wagon's customer service at 1-800-834-7922.
View details Hide details
Air bags
2021-07-01
21V504000
General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk are expected to be mailed August 16, 2021. Owners will receive a second notice when the remedy is available. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. This recall supersedes NHTSA recall number 20V-736. GM's number for this recall is N202324251.