GMC Sierra 3500 Recalls

Make selection is required

NHTSA safety recall results (71)

Recall information provided by National Highway Traffic Safety Administration

Component not known

General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra vehicles, and model year 2015 GMC Yukon and Chevrolet Suburban and Tahoe vehicles. In the affected vehicles, an electrical signal short may cause the transfer case to shift to neutral without the driver's input.

Recall consequence: If the transfer case switches to neutral while the vehicle is parked and the parking brake is not in use, the vehicle may roll away increasing the risk of injury to bystanders. If the transfer case switches to neutral while the vehicle is being driven, the vehicle would lose drive power, increasing the risk of a crash.
Recall action: GM will notify owners, and dealers will re-program the software in the transfer case control module, free of charge. The recall is expected to begin in early August 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14192.

Component not known

General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado 2500 and 3500 HD vehicles manufactured October 1, 2013 to June 6, 2014, and 2015 GMC Sierra 2500 and 3500 HD vehicles manufactured September 30, 2013, to June 6, 2014. The power steering hose clamp may disconnect from the power steering pump or gear, causing a loss of power steering fluid.

Recall consequence: A loss of power steering fluid could result in a loss of power steering assist and power brake assist, increasing the risk of a crash.
Recall action: GM will notify owners, and dealers will inspect the vehicles to make sure the power steering hose clamps are properly secured, free of charge. The recall is expected to begin in early August 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet) or 1-800-462-8782 (GMC). GM's number for this recall is 14356.

Electrical system, seat belts

General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra, and 2015 Chevrolet Tahoe and Suburban vehicles equipped with a base radio and an internal amplifier. The radios in the affected vehicles may become inoperative, and as a result, there would be no audible chime to notify the driver if the door is opened with the key in the ignition or no audible seat belt warning indicating the seat belts were not buckled. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Protection and Rollaway Prevention," and 208, "Occupant Crash Protection."

Recall consequence: Without an audible indicator, the driver may not be aware that the driver's door is open while the key is in the ignition, increasing the risk of a vehicle rollaway. Additionally, there would be no reminder that the driver's or front seat passenger's seat belt is not buckled, which could increase the risk of injury in a crash.
Recall action: GM will notify owners, and dealers will update the radio software, free of charge. The manufacturer has not yet provided a notification schedule. Chevrolet owners may contact GM's customer service at 1-800-222-1020. GMC owners may contact GM's customer service at 1-800-462-8782. GM's number for this recall is 14315.

Component not known

General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado HD vehicles manufactured January 8, 2014, through February 27, 2014, and 2015 GMC Sierra HD vehicles manufactured January 9, 2014, through February 14, 2014, and equipped with a 220 Amp Generator (RPO KW5). In the affected vehicles, the retention clips that attach the fuse block to the vehicle body can become loose allowing the fuse block to move out of position. If this occurs, exposed conductors in the fuse block may contact the mounting studs or other metallic components, causing a short to ground event.

Recall consequence: This could result in an arcing condition, and combustible materials located nearby could ignite and result in an engine compartment fire.
Recall action: GM will notify owners, and dealers will inspect the fuse block to verify that it is properly secured, repairing it as necessary, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet) or 1-800-462-8782 (GMC). GM's number for this recall is 14208.

Component not known

General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado HD, and GMC Sierra HD vehicles manufactured February 11, 2014, through February 19, 2014, and equipped with diesel engines and dual fuel tanks. In the affected vehicles, the fuel pipe connections on both sides of the diesel fuel transfer pump may not be properly torqued which may result in a diesel fuel leak.

Recall consequence: A fuel leak in the presence of an ignition source may result in a vehicle fire.
Recall action: GM will notify owners, and dealers will tighten the fuel pipe connections to the proper torque. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-462-8782 (GMC). General Motors' number for this recall is 14067.

Fuel system, diesel

General Motors LLC (GM) is recalling certain model year 2012-2013 Chevrolet Silverado HD and GMC Sierra HD vehicles, equipped with 6.6L diesel engines and dual fuel tanks. In the affected vehicles, the transfer pump which moves fuel from the rear tank to the front tank could malfunction and cause the fuel gauge to indicate an inaccurate reading.

Recall consequence: If the fuel gauge indicates an inaccurate reading it may result in the vehicle unexpectedly stalling, increasing the risk of a crash.
Recall action: General Motors will notify owners and dealers will inspect and replace the fuel transfer pump, as necessary, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet at 1-800-222-1020 and GMC at 1-800-462-8782. GM's number for this recall is 13420.

Power train, steering

General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.

Recall consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.
Recall action: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.

Seat belts: Front

GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET COLORADO AND GMC CANYON VEHICLES, MANUFACTURED FROM SEPTEMBER 9, 2011, THROUGH OCTOBER 19, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 208, "OCCUPANT CRASH PROTECTION." THESE VEHICLES MAY HAVE BEEN PRODUCED WITH DRIVER SAFETY BELT BUCKLE ELECTRICAL CONNECTOR TERMINALS THAT DO NOT FIT SNUGLY WITH THE CONNECTOR PINS, CAUSING THE CONNECTION TO BE INTERMITTENT.

Recall consequence: THE LOOSE CONNECTIONS MAY CAUSE THE DRIVER TO NOT RECEIVE A VISUAL OR AUDIBLE WARNING THAT THE DRIVER SEAT BELT IS NOT FASTENED, THEREBY INCREASING THE RISK OF PERSONAL INJURY IN THE EVENT OF A CRASH.
Recall action: GM WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE SEAT BELT BUCKLE ELECTRICAL CONNECTOR TERMINALS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE NOVEMBER 30, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.

Equipment

MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.

Recall consequence: AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.
Recall action: MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING SEPTEMBER 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.

Electrical system

GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.

Recall consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Recall action: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.