Kia Recalls

CURT MANUFACTURING IS RECALLING CERTAIN TOW PACKAGE WIRING HARNESSES, PART NUMBER 56024, THAT CONNECT TOW VEHICLE LIGHTING CIRCUITS TO TRAILER LIGHTING CIRCUITS SOLD FOR USE ON CERTAIN MODEL YEAR 2009 THROUGH 2011 HYUNDAI VERACRUZ AND KIA SORENTO VEHICLES. THE UNITS ARE NOT WATER-TIGHT AND MOISTURE CAN SEEP INTO THE CONVERTER MODULE AND DEFEAT THE MODULE'S INTERNAL CIRCUIT PROTECTION.

KIA IS RECALLING CERTAIN MODEL YEAR 2007-2008 SORENTO PASSENGER CARS MANUFACTURED FROM JUNE 15, 2006 THROUGH NOVEMBER 27, 2007. THE FRONT PASSENGER AIR BAG MAY BE TURNED OFF WHEN AN ADULT IS IN THE PASSENGER SEAT. THE FRONT PASSENGER AIR BAG IS DESIGNED TO BE TURNED OFF IN LIMITED CIRCUMSTANCES INCLUDING WHEN CHILDREN AND SMALL ADULTS ARE SEATED IN THE FRONT PASSENGER SEAT, THERE IS A CHILD RESTRAINT IN THAT SEAT OR THE SEAT IS NOT OCCUPIED. THE VEHICLE'S OCCUPANT CLASSIFICATION SYSTEM (OCS), WHICH CLASSIFIES THE OCCUPANT IN THE FRONT PASSENGER SEAT, MAY MISCLASSIFY AN ADULT PASSENGER AS A CHILD OR CHILD SEAT AND IMPROPERLY TURN OFF THE PASSENGER SIDE AIR BAG. WHEN THE AIR BAG IS DEACTIVATED THE "PASSENGER AIR BAG OFF" LIGHT WILL ILLUMINATE ON THE CENTER INSTRUMENT PANEL.

KIA IS RECALLING CERTAIN MODEL YEAR 2011 SORENTO 2WD VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND 2.4L ENGINES MANUFACTURED FROM THE START OF PRODUCTION THROUGH MAY 22, 2010. THE INTERMEDIATE SHAFT MAY SUFFER FROM NOISE AND EXCESSIVE WEAR DUE TO A MISALIGNMENT OF THE INTERMEDIATE SHAFT WITH THE RIGHT SIDE OUTPUT GEAR. CONTINUING TO DRIVE THE VEHICLE IN THIS CONDITION LEADS TO THE DEVELOPMENT OF A WHIRRING/WHINING NOISE AND CAN EVENTUALLY CAUSE DAMAGE TO THE AUTOMATIC TRANSMISSION.

KIA IS RECALLING CERTAIN MODEL YEAR 2006-2008 OPTIMA VEHICLES MANUFACTURED FROM SEPTEMBER 29, 2005, THROUGH JUNE 13, 2007. THERE IS A POSSIBILITY THAT THE SHIFT CABLE MAY HAVE BEEN INSTALLED INCORRECTLY, CAUSING TENSION IN THE CABLE. IF PRESENT, THIS CONDITION COULD CAUSE THE CABLE TO DETACH FROM THE SHIFTER ASSEMBLY'S DOWEL PIN PREVENTING THE TRANSMISSION FROM BEING SHIFTED. THE SHIFT LEVER CAN THEN BE MOVED INTO THE PARK (P) POSITION WHILE THE VEHICLE'S TRANSMISSION IS STILL IN THE LAST USED GEAR BEFORE DETACHMENT.

KIA IS RECALLING CERTAIN MODEL YEAR 2011 SORENTO VEHICLES MANUFACTURED FROM SEPTEMBER 14, 2010, THROUGH OCTOBER 4, 2010. SOME OF THE REAR BRAKE CALIPERS MAY NOT HAVE BEEN PROPERLY MACHINED.

HYUNDAI-KIA IS RECALLING CERTAIN MODEL YEAR 2010 SOUL AND MODEL YEAR 2011 SORENTO VEHICLES MANUFACTURED FROM SEPTEMBER 7, 2009 THROUGH JULY 30, 2010. A LIMITED NUMBER OF WIRING HARNESSES SUPPLIED BY JCI AND USED FOR THE LIGHTING IN THE KIA SOUL VEHICLES ADVANCED LIGHTING SPEAKERS, LOCATED IN THE FRONT DOOR TRIM PANELS, AND THE KIA SORENTO VEHICLES INTERIOR ACCENT ILLUMINATION, LOCATED IN THE FRONT AND REAR DOOR TRIM PANELS, MAY HAVE BEEN IMPROPERLY SOLDERED.

HYUNDAI-KIA IS RECALLING 139,844 MY 2006-2007- SEDONA, SPORTAGE, SORENTO AND MY RONDO AND AMANTI VEHICLES. THE STOP LAMP SWITCH IN THE VEHICLE MAY HAVE BEEN DAMAGED DURING THE ASSEMBLY PROCESS. AS A RESULT, THE STOP LAMP SWITCH MAY MALFUNCTION CAUSING ONE OR MORE OF THE FOLLOWING CONDITIONS TO EXIST: THE BRAKE LIGHTS MAY NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. ON SOME OCCASIONS, WHEN THE VEHICLE IS STARTED, THE SHIFTER CANNOT BE MOVED FROM THE PARK (P) POSITION. IF THE VEHICLE IS EQUIPPED WITH ELECTRONIC STABILITY CONTROL (ESC), THE ESC LIGHT MAY ILLUMINATE INDICATING "ESC OFF." IF THE VEHICLE IS EQUIPPED WITH CRUISE CONTROL, DEPRESSING THE BRAKE MAY NOT DEACTIVATE THE CRUISE CONTROL SYSTEM.

KIA IS RECALLING 6,680 MY 2008-2009 RONDO LX AND EX VEHICLES EQUIPPED WITH A 2.4 LITER ENGINE. THE FUEL PUMP MAY NOT OPERATE PROPERLY RESULTING IN NOT ENOUGH FUEL GETTING TO THE ENGINE. POOR ENGINE STARTING, ENGINE HESITATION, AND OTHER IMPAIRMENT MAY RESULT, AND THE CHECK ENGINE LIGHT MAY ILLUMINATE.

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE BRAKE PEDALS, THE STOP LAMP SWITCH WIRING HARNESS MAY BE OUT OF POSITION. AN IMPROPERLY POSITIONED STOP LAMP SWITCH WIRING HARNESS COULD MAKE CONTACT WITH THE U-JOINT ASSEMBLY OF THE STEERING COLUMN. REPEATED CONTACT MAY EVENTUALLY CAUSE THE WIRING HARNESS INSULATION TO WEAR THROUGH LEADING TO CHAFFED WIRES.

ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.