Lexus Recalls
Search for recalls by car
Make selection is required
NHTSA safety recall results (80)
Recall information provided by National Highway Traffic Safety Administration
Air bags: Frontal: Passenger side: Inflator module
2016-12-20
16V937000
Toyota Motor Engineering & Manufacturing (Toyota) is recalling one 2016 Toyota 4Runner vehicle manufactured November 1, 2016 and one 2017 Lexus GX460 vehicle manufactured November 16, 2016. The affected vehicles are equipped with Takata PSPI-LD front passenger air bag inflators that may have been manufactured without ignition booster tablets. As a result, in the event of a crash, the air bag may not fully inflate during deployment of the primary stage. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
The improper inflation of the passenger air bag may increase the risk of injury in the event of a crash.
Toyota dealers have replaced the passenger side air bag modules, free of charge. Toyota notified the affected dealers on December 15, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G06, GLR.
View details Hide details
Suspension
2016-08-12
16V596000
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall is expected to begin September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
View details Hide details
Air bags
2016-06-30
16V487000
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.
If either portion of the curtain shield air bag inflator ejects into the passenger cabin, there is an increased risk of injury to vehicle occupants.
Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall is expected to begin July 25, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota's number for this recall is Toyota G0U, and Lexus GLJ.
View details Hide details
Air bags
2016-05-23
16V340000
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2011 Scion xB and Lexus IS F, 2009-2011 Toyota Corolla and Corolla Matrix, 2006-2011 Toyota Yaris, Lexus IS250 and Lexus IS350, 2010-2011 Toyota 4Runner, Lexus IS250C, Lexus IS350C and Lexus GX460, 2011 Sienna, 2007-2011 Lexus ES350, and 2009-2010 Pontiac Vibe vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain model year 2008 Scion xB and Lexus IS F, 2007-2008 Toyota Yaris, 2006-2008 Lexus IS250 and Lexus IS350 and 2007-2008 Lexus ES350 vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jer...
An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Toyota will notify the Toyota and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. An interim notification was mailed to owners July 6, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for interim notification for this campaign are G1P (Toyota Zone A), G1R (Toyota Zone B), G2G (Lexus Zone A), and G2H (Lexus Zone B). Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), GLG (Lexus Zone A), and GLH (Lexus Zone B).
View details Hide details
Service brakes, hydraulic: Antilock/traction control/electronic limited slip
2016-04-06
16V198000
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015, to February 29, 2016. These vehicles are equipped with an ABS actuator that may have a damaged O-ring which could result in improper brake fluid pressure control during ABS, Traction Control, or Stability Control activation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect the brake actuator, replacing it as necessary, free of charge. The recall began on May 4, 2016, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0I, GLC.
View details Hide details
Air bags
2016-02-05
16V065000
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags. The affected vehicles have an air bag control module that may be improperly programmed, causing the side curtain-shield-air bags to deploy inadvertently.
If the side curtain-shield-air bags deploy unexpectedly, it can increase the risk of occupant injury.
Toyota will notify owners, and dealers will replace the air bag control module with one that has improved programming, free of charge. Owners were sent interim notices on March 1, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Toyota customer service at 1-888-271-9371. Toyota's number for this recall is G0C and GLB.
View details Hide details
Air bags: Knee bolster
2016-01-31
16V053000
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Lexus RX350 and RX450h vehicles manufactured November 16, 2015, to December 23, 2015. Due to an improper weld, the gas needed to inflate the driver's knee air bag may escape from the inflator.
A defective inflator may increase the risk of injury in the event of a crash.
Toyota will notify owners, and dealers will inspect and, if necessary, replace the knee air bag assembly, free of charge. The recall began March 7, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is GLA.
View details Hide details
Forward collision avoidance
2015-11-03
15V728000
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2013-2015 Avalon and Avalon Hybrid vehicles manufactured October 19, 2012 to October 27, 2015 and 2013-2015 Lexus ES350 and ES300h vehicles manufactured June 18, 2012 to July 6, 2015. The affected vehicles are equipped with a Pre-Collision System (PCS) as optional equipment. In these vehicles, the PCS may unexpectedly activate and apply the brakes when the radar detects a steel joint or plate in the roadway as an object.
A vehicle that unexpectedly brakes increases the risk of a crash.
Remedy parts for a permanent fix for this issue are not yet available. On November 18, 2015, Toyota sent owners an interim notification and dealers will temporarily disable the PCS. When the improved PCS components are available for the permanent remedy, owners will be mailed a second notification. These repairs will be performed free of charge. Owners may contact Toyota at 1-888-270-9371. Toyota's numbers for this campaign are F1V and F2E.
View details Hide details
Service brakes, hydraulic: Antilock/traction control/electronic limited slip
2015-06-02
15V341000
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Lexus NX200t vehicles manufactured December 18, 2014, to February 2, 2015. These vehicles are equipped with an Anti-Lock Braking System (ABS), Traction Control System (TRAC), and Vehicle Stability Control System (VSC) which are controlled by an ABS actuator. A component inside the actuator may have been damaged during its assembly and may cause the actuator to not function properly.
Under some driving conditions, when the ABS is activated, the malfunctioning ABS actuator could cause a loss of vehicle stability, increasing the risk of a crash.
Toyota will notify owners, and dealers will inspect and replace the ABS actuator, as necessary, free of charge. The recall began on July 21, 2015. Owners may contact Toyota customer service at 1-800-331-4331.
View details Hide details
Air bags
2015-05-13
15V286000
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.
In the event of a crash necessitating deployment of the front passenger's frontal air bag, the inflator could rupture with metal fragments striking and potentially seriously injuring the passenger seat occupant or other occupants.
Toyota will notify owners, and dealers will replace the passenger side front air bag, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Pontiac Vibe owners may contact GM at 1-800-762-2737. Note: This recall is an expansion of recall 14V-655.