Mazda Mazda5 Recalls
Search for recalls by car
Make selection is required
NHTSA safety recall results (5)
Recall information provided by National Highway Traffic Safety Administration
Structure: Body: Hatchback/liftgate
2016-09-05
16V644000
Mazda North American Operations (Mazda) is recalling certain model year 2010-2013 Mazda3 and Mazdaspeed3 vehicles manufactured November 18, 2008, to June 8, 2013, 2012-2015 Mazda5 vehicles manufactured October 26, 2010, to June 22, 2015, 2016 CX-3 vehicles manufactured June 1, 2015, to December 26, 2015, and 2013-2016 CX-5 vehicles manufactured December 15, 2011, to December 26, 2015. On the affected vehicles, the lift gate support struts may corrode, possibly causing the struts to break and/or the lift gate to drop unexpectedly.
If the lift gate falls unexpectedly, it may hit the user, increasing their risk of injury.
Mazda dealers will replace the both lift gate supports, free of charge, however parts are not currently available. The recall began April 2017. Owners may contact Mazda customer service at 1-800-222-5500. Mazda's number for this recall is 9916H.
View details Hide details
Fuel system, other: Delivery: Fuel pump
2010-11-24
10V600000
MAZDA IS RECALLING CERTAIN MODEL YEAR 2009-2010 MAZDA5 VEHICLES MANUFACTURED FROM JUNE 29, 2009, THROUGH APRIL 28, 2010. WATER MAY NOT HAVE BEEN REMOVED COMPLETELY FROM THE HARNESS CONNECTOR OF THE FUEL PUMP DUE TO VARIATIONS IN THE FUEL TANK LEAK CHECK PROCESS PERFORMED BEFORE VEHICLE ASSEMBLY. THE CONNECTOR PIN MAY CORRODE, POTENTIALLY CAUSING THE PIN TO BREAK.
THIS COULD LEAD TO AN INOPERATIVE FUEL PUMP, ENGINE STALL AND THE INABILITY TO RESTART THE ENGINE INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE FUEL PUMP CONNECTOR AND IF NECESSARY IT WILL BE REPLACED AND THE HARNESS WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE DECEMBER 11, 2010. OWNERS MAY CONTACT MAZDA CUSTOMER ASSISTANCE CENTER AT 1-800-222-5500.
View details Hide details
Equipment
2009-03-31
09E011000
THULE, INC. IS RECALLING 2,323 OWNER-INSTALLED ROOF-MOUNTED FIT KITS, MODELS 3068 AND 3069, MANUFACTURED BETWEEN JANUARY 1, 2008 AND FEBRUARY 28, 2009 THAT ARE USED WITH THULE PODIUM FOOT PACKS, MODELS 460 AND 460R. THESE FIT KITS WERE SOLD AS AFTERMARKET EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE BOLT(S) USED TO SECURE THE FOOT TO THE VEHICLE WAS MANUFACTURED TO A HARDNESS THAT MAY CAUSE THE BOLT(S) TO BE BRITTLE AND POTENTIALLY BREAK UNDER STRESS.
THIS MAY RESULT IN THE BOLT(S) SNAPPING OFF DURING USE OR WITHOUT A LOAD. THE UNSECURED RACK AND LOAD CAN THEN COME LOOSE WHILE DRIVING CREATING A POTENTIAL ROAD HAZARD, POSSIBLY RESULTING IN A VEHICLE CRASH.
THULE WILL MAIL A RETRO FIT KIT ALONG WITH REPAIR INSTRUCTIONS TO OWNERS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 13, 2009. OWNERS MAY CONTACT THULE TOLL-FREE AT 1-800-238-2388.
View details Hide details
Latches/locks/linkages: Doors: Latch
2006-11-30
06V463000
ON CERTAIN PASSENGER VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. THE SIDE DOOR LATCH MECHANISMS MAY EXPERIENCE WATER INTRUSION ALLOWING THE LATCH MECHANISM TO FREEZE IN COLD WEATHER.
AS A RESULT, WHEN THE DOOR IS OPENED THE DOOR LATCH PAWL MAY REMAIN IN THE OPEN POSITION RESULTING IN THE DOOR NOT BEING ABLE TO BE CLOSED AND LATCHED. IF THE VEHICLE IS OPERATED WITH AN OPEN DOOR IT MAY ALLOW AN UNBELTED OCCUPANT TO BE EJECTED FROM THE VEHICLE WHICH COULD RESULT IN INJURY OR DEATH.
DEALERS WILL REPLACE THE SLIDING DOOR LATCHES WITH MODIFIED LATCHES. THE RECALL IS EXPECTED TO DURING DECEMBER 2006. OWNERS MAY CONTACT MAZDA AT 1-800-222-5500.
View details Hide details
Engine and engine cooling: Exhaust system
2005-09-16
05V412000
ON CERTAIN SPORT UTILITY VEHICLES, A HEAT BUILDUP IN THE EXHAUST SYSTEM CAN OCCUR.
THIS CONDITION COULD RESULT IN A FIRE.
MAZDA WILL INSTRUCT OWNERS TO BRING IN THEIR VEHICLES AND WILL BE GIVEN A RENTAL OR LOANER VEHICLE AT NO COST WHILE MAZDA DEVELOPS A REMEDY AND MAKES REPAIRS. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.