Ford Explorer Recalls

There are currently 66 recalls for your vehicle. Change vehicle

NHTSA Vehicle Safety Recalls

  • Recall Number
    99V164000
    Recall Date
    06/29/1999
    Component
    LATCHES/LOCKS/LINKAGES:HOOD:LATCH
    Summary

    VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE SECONDARY HOOD LATCH MAY CORRODE AT THE LATCH PIVOT AND STICK IN THE OPEN POSITION.

    Consequence

    IF THIS OCCURS AND THE PRIMARY HOOD LATCH IS EITHER NOT ENGAGED OR IS RELEASED, A HOOD FLY-UP COULD OCCUR.

    What Owners Should Do

    DEALERS WILL INSTALL A SECONDARY HOOD LATCH WITH COMPONENTS THAT ARE COATED PRIOR TO ASSEMBLY FOR IMPROVED LATCH PIVOT CORROSION PROTECTION.

  • Recall Number
    09V399000
    Recall Date
    10/13/2009
    Component
    VEHICLE SPEED CONTROL
    Summary

    FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

    Consequence

    A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

    What Owners Should Do

    FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

  • Recall Number
    03V281000
    Recall Date
    08/05/2003
    Component
    SEATS:FRONT ASSEMBLY:RECLINER
    Summary

    ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.

    Consequence

    THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.

    What Owners Should Do

    DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

  • Recall Number
    06E026000
    Recall Date
    03/23/2006
    Component
    EXTERIOR LIGHTING
    Summary

    CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

    Consequence

    WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

    What Owners Should Do

    PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

  • Recall Number
    14E001000
    Recall Date
    01/06/2014
    Component
    STEERING
    Summary

    Ford Motor Company (Ford) is recalling certain replacement steering gears installed on model year 2011-2012 Explorers as service parts in September 2013 and January 2014. The affected gears may lock, preventing the driver from being able to steer the vehicle.

    Consequence

    The inability to steer the vehicle increases the risk of a crash.

    What Owners Should Do

    Ford will notify owners and dealers will replace the suspect steering gears with new steering gears, free of charge. The recall began on January 29, 2014. Customers may contact Ford at 1-800-392-3673. Ford's number for this recall is 13S14.

  • Recall Number
    98V060000
    Recall Date
    03/19/1998
    Component
    FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
    Summary

    VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 4.0L SINGLE OVERHEAD CAM ENGINES. THE ENGINE FUEL LINES CAN BE DAMAGED IF THE VEHICLE IS JUMP STARTED AND THE GROUND CABLE IS ATTACHED TO THE FUEL LINE BRACKET THAT IS LOCATED NEAR THE BATTERY. SINCE THE BRACKET IS NOT GROUNDED, THE STAINLESS STEEL FUEL LINE BRAID COULD ACT AS A GROUND POTENTIALLY OVERHEATING THE PTFE INNER LINER OF THE FUEL LINE RESULTING IN DAMAGE TO THE FUEL LINE.

    Consequence

    THE FUEL LINES CAN LEAK, AND IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD POTENTIALLY RESULT.

    What Owners Should Do

    DEALERS WILL INSTALL A WARNING LABEL ON THE FUEL LINE BRACKET ADVISING OWNERS NOT TO USE IT FOR A JUMP START GROUND. ALSO A REVISED BOLT WILL BE INSTALLED IN THE ALTERNATOR BRACKET TO PROVIDE A CONVENIENT JUMP START GROUND LOCATION.

  • Recall Number
    17E048000
    Recall Date
    08/28/2017
    Component
    WHEELS:CAP/COVER/HUB
    Summary

    Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.

    Consequence

    A loss of the wheel or wheel end can increase the risk of a crash.

    What Owners Should Do

    Ford will notify the distributors of the hubs specifying that they are to only be used on drive axles. It is believed that none of the hubs were purchased from Ford dealers for the incorrect application. Owners may contact Ford customer service at 1-866-436-7332.

  • Recall Number
    06V286000
    Recall Date
    08/01/2006
    Component
    VEHICLE SPEED CONTROL
    Summary

    ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

    Consequence

    OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

    What Owners Should Do

    DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

  • Recall Number
    09E012000
    Recall Date
    04/07/2009
    Component
    EXTERIOR LIGHTING
    Summary

    SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

    Consequence

    DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

    What Owners Should Do

    SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

  • Recall Number
    99V062001
    Recall Date
    03/30/1999
    Component
    VEHICLE SPEED CONTROL
    Summary

    VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.

    Consequence

    IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.

    What Owners Should Do

    DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.

  • Recall Number
    17V530000
    Recall Date
    08/28/2017
    Component
    STEERING
    Summary

    Ford Motor Company (Ford) is recalling certain 2017 Explorer, Taurus and Police Interceptor Utility and Sedan vehicles. The steering gear heat shield fasteners may corrode, allowing the heat shield to detach.

    Consequence

    If the heat shield detaches, the steering gear may overheat, increasing the steering effort required by the driver, especially at lower speeds, and increasing the risk of a crash.

    What Owners Should Do

    Ford will notify owners, and dealers to inspect and replace the heat shield fasteners as needed, free of charge. The recall began on September 13, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S23.

  • Recall Number
    95I007000
    Recall Date
    01/31/1996
    Component
    STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE
    Summary

    VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH FEDERAL REGULATION 573. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. THE CAMPAIGN WILL REINFORCE THE BRACKET ATTACHMENTS OF THE REAR LIFTGATE GAS ASSIST CYLINDERS WHICH COULD PULL AWAY FROM THE INSIDE OF THE LIFTGATE.

    Consequence

    IF A BRACKET AND GAS ASSIST CYLINDER WERE TO DETACH COMPLETELY FROM THE LIFTGATE AND NO LONGER BEAR AGAINST THE LIFTGATE AS INTENDED, THE REMAINING ASSIST CYLINDER WOULD NOT HOLD THE LIFTGATE IN AN OPEN POSITION. PERSONAL INJURY COULD OCCUR.

    What Owners Should Do

    FORD DEALERS WILL REINFORCE THE BRACKET ATTACHMENTS.

  • Recall Number
    97V083000
    Recall Date
    05/05/1997
    Component
    VISIBILITY:REARVIEW MIRRORS/DEVICES
    Summary

    A SHORT CIRCUIT CONDITION CAN OCCUR IN THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AS A RESULT OF A SEPARATED PART OF THE CONTACT ASSEMBLY BRIDGING THE SWITCH POSITIVE BATTERY PAD AND ADJACENT CHASSIS GROUND PAD.

    Consequence

    THE CURRENT CAN OVERHEAT THE PRINTED CIRCUIT BOARD AND OTHER PLASTIC AND ELASTOMERIC COMPONENTS OF THE SWITCH ASSEMBLY RESULTING IN SMOKE OR FIRE.

    What Owners Should Do

    DEALERS WILL INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.

  • Recall Number
    10E043000
    Recall Date
    09/03/2010
    Component
    EQUIPMENT
    Summary

    MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.

    Consequence

    AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.

    What Owners Should Do

    MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.

  • Recall Number
    00V395000
    Recall Date
    11/28/2000
    Component
    POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
    Summary

    VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH THE 3.27 OR 3.55 AXLE RATION. THE SUBJECT VEHICLES HAVE A POWERTRAIN CONTROL MODULE THAT COULD ALLOW THE VEHICLE TO EXCEED THE DESIGN INTENT TOP SPEED. AT THESE EXTREME SPEEDS, THE VEHICLE COULD BE CAPABLE OF EXCEEDING THE SPEED RATING OF THE TIRE.

    Consequence

    OPERATING THE VEHICLE ABOVE THE MAXIMUM SPEED RATING COULD LEAD TO A TIRE FAILURE WHICH AT THESE SPEEDS COULD RESULT IN A CRASH.

    What Owners Should Do

    DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE.

  • Recall Number
    07V181000
    Recall Date
    04/25/2007
    Component
    STEERING
    Summary

    ON CERTAIN SPORT UTILITY VEHICLES, THE TWO BOLTS THAT ATTACH THE STEERING GEAR ASSEMBLY TO THE FRAME MAY HAVE BEEN OVER-TIGHTENED. THIS CONDITION COULD RESULT IN ONE OR BOTH OF THE BOLTS FRACTURING, CAUSING THE STEERING GEAR TO BECOME LOOSE.

    Consequence

    THIS CONDITION COULD CAUSE "CLUNKING" NOISE WHEN STEERING AS WELL AS DECREASED STEERING EFFECTIVENESS POTENTIALLY RESULTING IN A CRASH.

    What Owners Should Do

    DEALERS WILL REPLACE BOTH THE STEERING GEAR ASSEMBLY MOUNTING BOLTS AND NUTS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

  • Recall Number
    01X001000
    Recall Date
    05/22/2001
    Component
    TIRES:TREAD/BELT
    Summary

    THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.

    Consequence

    SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.

    What Owners Should Do

    THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.

  • Recall Number
    03V094000
    Recall Date
    03/07/2003
    Component
    STRUCTURE
    Summary

    CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.

    Consequence

    THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

    What Owners Should Do

    DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.

  • Recall Number
    00V402000
    Recall Date
    11/28/2000
    Component
    SUSPENSION
    Summary

    VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE.

    Consequence

    VEHICLE HANDLING COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.

    What Owners Should Do

    DEALERS WILL REPLACE BOTH THE LEFT AND RIGHT FRONT SWAY BAR LINKS.

  • Recall Number
    00T005000
    Recall Date
    08/21/2000
    Component
    TIRES:TREAD/BELT
    Summary

    TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.

    Consequence

    IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.

    What Owners Should Do

    THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.

  • Recall Number
    03V280000
    Recall Date
    08/05/2003
    Component
    VEHICLE SPEED CONTROL:CABLES
    Summary

    ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.

    Consequence

    THE THROTTLE RETURN SPRING FORCE MAY NOT BE SUFFICIENT TO OVERCOME THE BINDING CONDITION WHEN THE SPEED CONTROL IS DISENGAGED. BRAKING FUNCTION WOULD BE MAINTAINED THOUGH STOPPING DISTANCES MAY BE INCREASED.

    What Owners Should Do

    DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

  • Recall Number
    04V442000
    Recall Date
    09/13/2004
    Component
    STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS
    Summary

    ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.

    Consequence

    IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.

    What Owners Should Do

    DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

  • Recall Number
    07E104000
    Recall Date
    12/11/2007
    Component
    VISIBILITY:GLASS, SIDE/REAR
    Summary

    CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

    Consequence

    IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

    What Owners Should Do

    SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

  • Recall Number
    14V286000
    Recall Date
    05/29/2014
    Component
    STEERING:ELECTRIC POWER ASSIST SYSTEM
    Summary

    Ford Motor Company (Ford) is recalling certain model year 2011-2013 Ford Explorer vehicles manufactured May 17, 2010, through February 28, 2012. The affected vehicles may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting in a shut down of the power steering assist.

    Consequence

    If the vehicle experiences a loss of power steering assist it will require extra steering effort at lower speeds, increasing the risk of a vehicle crash.

    What Owners Should Do

    Ford will notify owners, and dealers will update the Power Steering Control Module (PSCM) software, free of charge. If a vehicle shows a history of a loss of motor position sensor signal when the vehicle is brought in for the recall remedy, its steering rack assembly will be replaced, free of charge. The recall began on July 23, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S06.

  • Recall Number
    00V168000
    Recall Date
    06/19/2000
    Component
    EXTERIOR LIGHTING
    Summary

    VEHICLE DESCRIPTION: MINI VANS, LIGHT PICKUP TRUCKS, AND SPORT UTILITY VEHICLES. OFF LEASE CANADIAN VEHICLES EQUIPPED WITH DAYTIME RUNNING LIGHTS WHICH MEET CANADIAN REQUIREMENTS AND NOT THE PHOTOMETRIC REQUIREMENTS OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ACCORDING TO FORD, THE VEHICLES WERE IMPORTED INTO THE U.S. ERRONEOUSLY.

    Consequence

    THE LIGHT GIVEN OFF FROM THE DAYTIME RUNNING LIGHTS IS BRIGHTER THAN ALLOWED BY U.S. STANDARDS.

    What Owners Should Do

    DEALERS WILL BE ADVISED TO DEACTIVATE THE RUNNING LIGHT FUNCTION AND TO COMPLETE ANY OUTSTANDING SAFETY RECALLS ON THESE VEHICLES.

  • Recall Number
    97V235001
    Recall Date
    12/18/1997
    Component
    STRUCTURE:BODY:ROOF AND PILLARS
    Summary

    VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH FACTORY INSTALLED SUNROOF. THE SUNROOF GLASS PANEL ASSEMBLY CAN SEPARATE WHILE THE VEHICLE IS MOVING DUE TO INCORRECT HINGE ENGAGEMENT. THIS WAS CAUSED BY IMPROPER SUNROOF INSTALLATION OF THE GLASS PANEL.

    Consequence

    UNEXPECTED SEPARATION OF THE SUNROOF GLASS PANEL COULD POSSIBLY DISTRACT THE DRIVER INCREASING THE RISK OF A VEHICLE CRASH OR LOSS OF VEHICLE CONTROL.

    What Owners Should Do

    OWNERS WILL BE PROVIDED WITH AN INSTRUCTION BOOKLET WHICH THOROUGHLY OUTLINES, WITH ILLUSTRATIONS, THE PROPER PROCEDURES FOR THE REMOVAL, STORAGE, AND REINSTALLATION OF THE SUNROOF'S GLASS PANEL. A WARNING LABEL FOR ATTACHMENT TO THE SUNROOF'S LATCH KNOB WILL ALSO BE PROVIDED TO THE OWNERS.

  • Recall Number
    09E025000
    Recall Date
    05/11/2009
    Component
    EXTERIOR LIGHTING:HEADLIGHTS
    Summary

    DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

    Consequence

    DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

    What Owners Should Do

    DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

  • Recall Number
    96V024001
    Recall Date
    02/05/1996
    Component
    SERVICE BRAKES, HYDRAULIC:POWER ASSIST:HYDRAULIC
    Summary

    THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.

    Consequence

    IF A CRACK OCCURS, IT COULD RESULT IN ONE OR BOTH STUDS FRACTURING. THE MASTER CYLINDER COULD THEN SEPARATE FROM THE VACUUM BOOSTER, WHEN THE BRAKES ARE APPLIED, PREVENTING THE SERVICE BRAKES FROM ACTIVATING INCREASING THE RISK OF A VEHICLE ACCIDENT.

    What Owners Should Do

    DEALERS WILL REPLACE THE POWER BRAKE VACUUM BOOSTER ASSEMBLY.

  • Recall Number
    01I010000
    Recall Date
    04/10/2001
    Component
    VISIBILITY:GLASS, SIDE/REAR
    Summary

    THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.

    Consequence

    ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.

    What Owners Should Do

    FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.

  • Recall Number
    17V332000
    Recall Date
    05/22/2017
    Component
    SEATS:FRONT ASSEMBLY:RECLINER
    Summary

    Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."

    Consequence

    If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.

    What Owners Should Do

    Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.

  • Recall Number
    99V310001
    Recall Date
    11/03/1999
    Component
    STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE
    Summary

    VEHICLE DESCRIPTION: ON CERTAIN SPORT UTILITY VEHICLES, THE HYDRAULIC LIFT CYLINDER BRACKET WELDS COULD FRACTURE.

    Consequence

    WITH A BROKEN BRACKET WELD, THERE IS A POTENTIAL FOR THE LIFTGATE BRACKET TO GRADUALLY BEND INWARD ALLOWING THE LIFT CYLINDER BALL STUD TO DISENGAGE, UNEXPECTEDLY ALLOWING THE LIFTGATE TO FALL FROM AN OPEN POSITION.

    What Owners Should Do

    DEALERS WILL INSTALL LIFTGATE REINFORCEMENT BRACKETS. DEPENDING UPON THE CONDITION OF THE LIFTGATE SHEET METAL IN THE AREA OF THE BRACKET, DEALERS MAY ALSO INSTALL A LARGER REINFORCEMENT.

  • Recall Number
    96V070000
    Recall Date
    04/22/1996
    Component
    LATCHES/LOCKS/LINKAGES:DOORS:LATCH
    Summary

    WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."

    Consequence

    THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.

    What Owners Should Do

    DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.

  • Recall Number
    95V164001
    Recall Date
    08/25/1995
    Component
    STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE
    Summary

    THE HYDRAULIC LIFT CYLINDERS ARE ATTACHED TO BRACKETS THAT ARE WELDED TO THE LIFTGATE. THE BRACKET WELDS CAN FRACTURE.

    Consequence

    WITH A BROKEN BRACKET WELD, THERE IS A POTENTIAL FOR THE LIFTGATE BRACKET TO GRADUALLY BEND INWARD ALLOWING THE LIFT CYLINDERBALL STUD TO DISENGAGE.

    What Owners Should Do

    DEALERS WILL INSTALL REINFORCEMENT BRACKETS.

  • Recall Number
    96V161000
    Recall Date
    08/29/1996
    Component
    EQUIPMENT:OTHER:LABELS
    Summary

    THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

    Consequence

    INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .

    What Owners Should Do

    OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.

  • Recall Number
    06E049000
    Recall Date
    05/24/2006
    Component
    EXTERIOR LIGHTING
    Summary

    CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

    Consequence

    WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

    What Owners Should Do

    CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

  • Recall Number
    16V925000
    Recall Date
    12/22/2016
    Component
    ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO-CHARGER
    Summary

    Ford Motor Company (Ford) is recalling certain model year 2016 Ford Taurus, 2016-2017 Ford Flex, Lincoln MKT, 2017 Ford Explorer and Ford Explorer Police Interceptor Utility vehicles equipped with 3.5L GTDI engines. Improperly brazed turbocharger oil supply tubes may leak oil on engine components.

    Consequence

    An oil leak, in the presence of an ignition source, increases the risk of a fire.

    What Owners Should Do

    Ford will notify owners, and dealers will inspect, and if necessary, replace the turbocharger oil supply tubes, free of charge. The recall began on January 31, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S46.

  • Recall Number
    15V171000
    Recall Date
    03/24/2015
    Component
    STRUCTURE:BODY:DOOR
    Summary

    Ford Motor Company (Ford) is recalling certain model year 2011-2013 Explorer vehicles. In the affected vehicles, the interior door handle return spring may unseat, resulting in interior door handle that does not return to the fully stowed position after actuation.

    Consequence

    If the interior door handle return spring is unseated, the door may unlatch in the event of a side impact crash, increasing the risk of personal injury.

    What Owners Should Do

    Ford will notify owners, and dealers will inspect all four of the interior door handles and either repair or replace them, free of charge. The recall began on July 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S11.

  • Recall Number
    13V227000
    Recall Date
    05/31/2013
    Component
    FUEL SYSTEM, GASOLINE
    Summary

    Ford is recalling certain model year 2013 Explorer, Taurus, Flex, Fusion, Police Interceptor Sedan and Police Interceptor Utility vehicles; and certain model year 2013 Lincoln MKS, MKT, and MKZ vehicles. In the affected vehicles, the fuel delivery module may develop a crack, allowing fuel to leak.

    Consequence

    A fuel leak in the presence of an ignition source may result in a fire.

    What Owners Should Do

    Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on July 20, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332. Ford's recall campaign number is 13S04.

  • Recall Number
    97V137000
    Recall Date
    08/19/1997
    Component
    STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE
    Summary

    VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THE LIFTGATE ASSIST GAS CYLINDER BRACKET ON THE RIGHT HAND BODYSIDE OUTER PANEL WAS INCORRECTLY WELDED.

    Consequence

    THE GAS CYLINDER BRACKET MAY NOT PROPERLY SUPPORT THE LIFTGATE INCREASING THE RISK OF PERSONAL INJURY.

    What Owners Should Do

    DEALERS WILL REINFORCE THE BRACKET ATTACHMENT WITH TWO POP RIVETS.

  • Recall Number
    00V228001
    Recall Date
    08/18/2000
    Component
    SEAT BELTS
    Summary

    VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

    Consequence

    IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.

    What Owners Should Do

    DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

  • Recall Number
    07V336000
    Recall Date
    08/03/2007
    Component
    VEHICLE SPEED CONTROL
    Summary

    ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

    Consequence

    THIS COULD RESULT IN AN UNDERHOOD FIRE.

    What Owners Should Do

    DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

  • Recall Number
    95V052000
    Recall Date
    03/15/1995
    Component
    SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
    Summary

    IN SOME OF THE VEHICLES, BRAKE TUBES WERE MISROUTED BETWEEN THE MASTER CYLINDER AND THE HYDRAULIC CONTROL UNIT AND RESULTS IN EXCEEDING THE ALLOWABLE STOPPING DISTANCES AS REQUIRED BY FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS." IN ADDITION, SEALS WITHIN THE MASTER CYLINDER COULD BE ABRADED BY THIS CONDITION OVER TIME RESULTING IN AN INTERNAL LEAK AND A FURTHER REDUCTION IN BRAKE PERFORMANCE.

    Consequence

    CONSEQUENCE OF NON-COMPLIANCE: STOPPING DISTANCES COULD BE LONGER THAN INTENDED RESULTING IN INCREASED POTENTIAL FOR A VEHICLE ACCIDENT.

    What Owners Should Do

    DEALERS WILL REROUTE THE BRAKE TUBES.

  • Recall Number
    07V453000
    Recall Date
    09/26/2007
    Component
    POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
    Summary

    ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH THE 4.6L ENGINE AND 6R TRANSMISSION, THE BOLT SECURING THE TRANSMISSION OIL COOLER LINE FITTINGS AT THE TRANSMISSION MAY NOT HAVE BEEN SUFFICIENTLY TORQUED DURING VEHICLE ASSEMBLY. AS A RESULT, THE BOLT MAY LOOSEN AND THE TRANSMISSION OIL COOLER LINES MAY DISENGAGE FROM THE TRANSMISSION, CAUSING A TRANSMISSION FLUID LEAK.

    Consequence

    IF LEAKING TRANSMISSION FLUID CONTACTS THE CATALYTIC CONVERTER, IT MAY POSE A RISK OF FIRE.

    What Owners Should Do

    DEALERS WILL INSPECT AND HAVE THE TRANSMISSION COOLER LINE ATTACHMENT BOLT TIGHTENED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 30, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

  • Recall Number
    00V179000
    Recall Date
    07/05/2000
    Component
    AIR BAGS:SIDE/WINDOW
    Summary

    VEHICLE DESCRIPTION: 4-DOOR SPORT UTILITY VEHICLES EQUIPPED WITH SIDE AIR BAGS. THE SUBJECT VEHICLES HAVE A REVISED LEVEL SIDE CRASH SENSOR THAT COULD DEPLOY THE SIDE AIR BAG IF THE IGNITION KEY IS IN THE "RUN" POSITION AND THE SEATBELT WEBBING IS FORCIBLY EXTRACTED FROM A LOCKED RETRACTOR WITH A JERKING MOTION.

    Consequence

    INADVERTENT SIDE AIR BAG DEPLOYMENT COULD CAUSE PERSONAL INJURY TO THE SEAT OCCUPANT.

    What Owners Should Do

    DEALERS WILL REPLACE THE SIDE CRASH SENSORS WITH A REVISED DESIGN THAT WILL REDUCE THE LIKELIHOOD OF AN UNEXPECTED SIDE AIR BAG DEPLOYMENT.

  • Recall Number
    16V183000
    Recall Date
    03/31/2016
    Component
    ENGINE AND ENGINE COOLING:ENGINE
    Summary

    Ford Motor Company (Ford) is recalling certain model year 2015-2016 Lincoln MKC vehicles manufactured November 25, 2013, to January 25, 2016, and 2016 Ford Explorer vehicles manufactured October 20, 2014, to January 28, 2016. The affected vehicles are equipped with 2.3L GTDI engines and engine block heaters. These engine block heaters have elements that may overheat while plugged in.

    Consequence

    Overheating of the engine block increase the risk of a fire.

    What Owners Should Do

    Ford will notify owners, and dealers will replace the engine block heater, free of charge. Dealers will also inspect and replace the electrical cord, as necessary. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S14. Note: Owners should not use the engine block heater until the vehicle has been remedied.

  • Recall Number
    94V169001
    Recall Date
    09/07/1994
    Component
    PARKING BRAKE:CONVENTIONAL
    Summary

    THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.

    Consequence

    WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.

    What Owners Should Do

    A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.

  • Recall Number
    13V270000
    Recall Date
    06/26/2013
    Component
    LATCHES/LOCKS/LINKAGES
    Summary

    Ford Motor Company (Ford) is recalling certain model year 2013 Ford Explorer, Taurus, and Lincoln MKS vehicles manufactured November 29, 2012, through December 12, 2012. In the affected vehicles, with sufficient door openings and closings, the child safety locks may change from an activated position to a deactivated position without notice.

    Consequence

    If the child lock is deactivated, the door could be unlocked and opened from the inside which could lead to personal injury to an unrestrained child.

    What Owners Should Do

    Ford will notify owners, and dealers will test the safety locks. If necessary, the locks will be replaced free of charge. The recall began on August 2, 2013. Ford's recall number is 13S07. Owners may contact the Ford customer relationship center at 1-866-436-7332.

  • Recall Number
    16V475000
    Recall Date
    06/28/2016
    Component
    SEATS:FRONT ASSEMBLY:RECLINER
    Summary

    Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

    Consequence

    The seat back may not adequately restrain the occupant during a crash, increasing the risk of injury.

    What Owners Should Do

    Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall begin on August 18, 2016. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 16C11.

  • Recall Number
    16V245000
    Recall Date
    04/26/2016
    Component
    SUSPENSION:REAR
    Summary

    Ford Motor Company (Ford) is recalling certain model year 2014-2015 Ford Explorer vehicles manufactured January 17, 2014 to May 31, 2014. The affected vehicles may have improperly welded rear suspension toe links that may fracture.

    Consequence

    A fracture of the rear suspension toe link may result in a loss of steering control, increasing the risk of a crash.

    What Owners Should Do

    Ford will notify owners, and dealers will replace the rear suspension toe links, free of charge. The recall began on November 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S18.

  • Recall Number
    95V053000
    Recall Date
    03/15/1995
    Component
    STEERING:LINKAGES:TIE ROD ASSEMBLY
    Summary

    THE INNER TIE ROD ASSEMBLIES WERE IMPROPERLY MANUFACTURED AND CAN FRACTURE CAUSING SHAKING OR SHIMMY AT LOW SPEEDS.

    Consequence

    THIS CONDITION CAN CAUSE THE WHEEL ON THE SIDE WITH THE BROKEN TIE ROD TO TUCK INWARD OR OUTWARD AND SLIDE RESULTING IN AN INCREASED POTENTIAL FOR A VEHICLE ACCIDENT.

    What Owners Should Do

    DEALERS WILL INSPECT THE INNER TIE RODS AND REPLACE THE SUSPECT TIE RODS.

  • Recall Number
    00V072000
    Recall Date
    03/07/2000
    Component
    ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS
    Summary

    VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES EQUIPPED WITH 4.0L ENGINES AND ALL-TIME 4-WHEEL DRIVE (A4WD) POWERTRAINS. THE GENERIC ELECTRONIC MODULE (GEM) COULD EXPERIENCE A CONDITION REFERRED TO AS "LOCK-UP" IN WHICH THE GEM CONTROLLED ELECTRONIC FUNCTIONS (E.G., FRONT WINDSHIELD WIPERS, INTERIOR LIGHTS, 4X4 SYSTEM, ETC.) COULD NOT BE TURNED ON OR, IN SOME CASES IF THE FUNCTION IS ON, COULD NOT BE TURNED OFF.

    Consequence

    AN INOPERATIVE WINDSHIELD WIPER SYSTEM COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.

    What Owners Should Do

    DEALERS WILL INSTALL A RESISTOR IN THE GEM CIRCUIT.

  • Recall Number
    06E056000
    Recall Date
    06/13/2006
    Component
    FUEL SYSTEM, GASOLINE
    Summary

    CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

    Consequence

    FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

    What Owners Should Do

    UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

  • Recall Number
    15V812000
    Recall Date
    12/02/2015
    Component
    FUEL SYSTEM, GASOLINE
    Summary

    Ford Motor Company (Ford) is recalling certain model year 2013 Explorer, Explorer Police Utility, Taurus, Taurus Police Interceptor, Flex, Lincoln MKS, and Lincoln MKT vehicles. In the affected vehicles, the fuel delivery module may crack, allowing fuel to leak.

    Consequence

    A fuel leak in the presence of an ignition source may result in a fire.

    What Owners Should Do

    Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on December 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 13S04-S1.

  • Recall Number
    13V109000
    Recall Date
    03/27/2013
    Component
    FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
    Summary

    Ford is recalling certain model year 2012 Taurus, Lincoln MKS, and model year 2013 Explorer vehicles manufactured July 19, 2011, through March 15, 2012. In the affected vehicles, the fuel tanks may have a marginally sealed seam in the side of the tank. As a result, the fuel tanks may not provide the expected strength in the event of an impact. The tanks may also leak.

    Consequence

    A fuel leak in the presence of an ignition source may result in a fire.

    What Owners Should Do

    Ford will notify owners, and dealers will inspect the fuel tanks and replace them as necessary, free of charge. The recall began on May 9, 2013. Ford's recall campaign number is 13S03. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.

  • Recall Number
    15V464000
    Recall Date
    07/24/2015
    Component
    PARKING BRAKE
    Summary

    Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Ford Flex, and Lincoln MKS vehicles manufactured May 4, 2015, to May 23, 2015, Lincoln MKT vehicles manufactured May 4, 2015, to May 21, 2015, and 2015-2016 Ford Explorer vehicles manufactured May 4, 2015, to May 23, 2015. The affected vehicles have a parking brake that may not fully engage when applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."

    Consequence

    If the parking brake does not fully engage and the transmission is left in a gear other than 'Park' while on a slope, the vehicle may roll away, increasing the risk of a crash.

    What Owners Should Do

    Ford will notify owners, and dealers will test the operation of the parking brake system, and if necessary, replace the parking brake control assembly, free of charge. The recall began on September 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C07.

  • Recall Number
    99V123000
    Recall Date
    05/18/1999
    Component
    SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
    Summary

    VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT FRONT BRAKE LINE TO THE HYDRAULIC CONTROL UNIT (HCU) CONNECTION COULD SEPARATE CAUSING THE LINE TO LEAK WHEN THE BRAKE PEDAL IS APPLIED.

    Consequence

    THIS COULD RESULT IN A LOSS OF BRAKE PRESSURE TO THE FRONT WHEELS, INCREASING THE STOPPING DISTANCE.

    What Owners Should Do

    DEALERS WILL REPLACE THE FLARE NUT ON THE BRAKE LINE.

  • Recall Number
    97V215000
    Recall Date
    11/24/1997
    Component
    ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT CONTROLLER
    Summary

    VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES, EDDIE BAUER AND LIMITED EDITIONS. THE KEY-IN-IGNITION/DOOR OPEN WARNING CHIME MAY NOT FUNCTION WHEN THE DOOR IS OPENED. THIS DOES NOT FULLY COMPLY WITH FMVSS NO. 114, "THEFT PROTECTION."

    Consequence

    THE STANDARD SPECIFIED THAT A WARNING TO THE DRIVER SHALL BE ACTUATED WHENEVER THE KEY HAS BEEN LEFT IN THE LOCKING SYSTEM AND THE DRIVER'S DOOR IS OPENED.

    What Owners Should Do

    DEALERS WILL INSTALL A JUMPER WIRE TO PROVIDE THE NECESSARY GROUND CIRCUIT IN THESE VEHICLES.

  • Recall Number
    10V161000
    Recall Date
    04/20/2010
    Component
    SEATS:FRONT ASSEMBLY:RECLINER
    Summary

    FORD IS RECALLING CERTAIN MODEL YEAR 2010 FUSION, EXPLORER, EXPLORER SPORT TRAC, AND MERCURY MILAN AND MOUNTAINEER VEHICLES MANUFACTURED BETWEEN DECEMBER 15, 2009 THROUGH FEBRUARY 3, 2010 EQUIPPED WITH FRONT SEAT MANUAL RECLINERS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202, "HEAD RESTRAINT." THE RECLINER GEAR PLATE TEETH MAY BE OUT OF DIMENSION SPECIFICATION WHICH COULD RESULT IN LIMITED PAWL TO GEAR PLATE TOOTH ENGAGEMENT.

    Consequence

    IN THE EVENT OF A CRASH, THE SEATBACK AND HEAD RESTRAINT MAY MOVE REARWARD, INCREASING THE RISK OF INJURY.

    What Owners Should Do

    DEALERS WILL REPLACE THE MANUAL RECLINERS FOR BOTH POWER AND MANUAL SEATS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 30, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

  • Recall Number
    95E006002
    Recall Date
    02/24/1995
    Component
    AIR BAGS:FRONTAL
    Summary

    THE PASSENGER SIDE AIR BAG HAS AN INFLATOR BODY THAT CRACKED DURING FORMING OF THE CURL THAT RETAINS THE IGNITER PLUG IN THE END OF THE INFLATOR. ALSO THE IGNITER END CAP CAN SEPARATE FROM THE INFLATOR.

    Consequence

    THE PASSENGER SIDE AIR BAG MAY NOT INFLATE PROPERLY RESULTING IN REDUCED OCCUPANT PROTECTION IN A VEHICLE ACCIDENT. IF THE IGNITER END CAP SEPARATES IN A FRONTAL COLLISION, HOT GASES CAN BE RELEASED AND IGNITE FLAMMABLE MATERIAL OR CAUSE BURN INJURIES.

    What Owners Should Do

    DEALERS WILL REMOVE AND REPLACE THE PASSENGER SIDE AIR BAG MODULE.

  • Recall Number
    00V422000
    Recall Date
    12/27/2000
    Component
    VEHICLE SPEED CONTROL
    Summary

    VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES AND STILL RETAIN THE ORIGINAL THROTTLE BODY (PART NUMBERS 97JF-9E926AB OR 97JF-9E926-AC). SOME OF THE ORIGINAL THROTTLE BODIES INSTALLED ALLOWED A GAP BETWEEN THE PLATE AND BORE TO BE BUILT TOO NARROW. THIS REDUCED CLEARANCE ALLOWED THE ENGINE DEPOSITS NORMALLY PRESENT IN THE THROTTLE BODY TO CONTACT OR BRIDGE THE GAP. IF THE ENGINE DEPOSITS BRIDGED THE GAP BETWEEN THE THROTTLE PLATE AND BORE AND THEN HARDENED, ON THE INITIAL APPLICATION OF THE ACCELERATOR PEDAL AFTER THE ENGINE HAS COOLED, THE OPERATOR WOULD NEED TO APPLY ADDITIONAL FORCE TO THE ACCELERATOR PEDAL TO BREAK THE BRIDGE.

    Consequence

    THIS COULD RESULT IN ENGINE SURGE WHEN THE ACCELERATOR PEDAL BREAKS FREE.

    What Owners Should Do

    DEALERS WILL REPLACE THE ORIGINAL THROTTLE BODIES.

  • Recall Number
    97V074000
    Recall Date
    04/30/1997
    Component
    VEHICLE SPEED CONTROL
    Summary

    VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.

    Consequence

    ALTHOUGH THE VEHICLE CAN BE CONTROLLED BY EITHER APPLYING THE SERVICE BRAKES OR SHIFTING THE TRANSMISSION TO NEUTRAL, INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE CAN RESULT.

    What Owners Should Do

    DEALERS WILL INSTALL A REVISED PCV SYSTEM WITH WATER HEATED VACUUM SOURCE.

  • Recall Number
    05V520000
    Recall Date
    11/09/2005
    Component
    VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
    Summary

    ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.

    Consequence

    AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.

    What Owners Should Do

    DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.

  • Recall Number
    11V063000
    Recall Date
    02/02/2011
    Component
    SEATS
    Summary

    FORD IS RECALLING CERTAIN MODEL YEAR 2011 EXPLORER VEHICLES MANUFACTURED FROM JULY 15, 2010, THROUGH DECEMBER 13, 2010, EQUIPPED WITH SECOND ROW 60% SEATS WITH MANUAL RECLINER MECHANISMS THAT MAY HAVE COMPONENTS THAT ARE OUT OF DIMENSIONAL SPECIFICATION. THESE SEATS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS."

    Consequence

    IN THE EVENT OF A CRASH, THE SEAT BACK MAY NOT PROVIDE THE REQUIRED STRENGTH, INCREASING THE RISK OF INJURY.

    What Owners Should Do

    FORD WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE SEATS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

  • Recall Number
    00V313000
    Recall Date
    10/17/2000
    Component
    EQUIPMENT:OTHER:LABELS
    Summary

    VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567.4, "CERTIFICATION." THESE VEHICLES WERE SHIPPED FROM THE ASSEMBLY PLANT WITHOUT SAFETY CERTIFICATION LABELS.

    Consequence

    INCORRECT TIRE INFLATION PRESSURE COULD RESULT IN TIRE TREAD SEPARATION, INCREASING THE RISK OF A CRASH.

    What Owners Should Do

    DEALERS WILL REPLACE THE CERTIFICATION LABELS.

  • Recall Number
    15V605000
    Recall Date
    09/28/2015
    Component
    FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
    Summary

    Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Lincoln MKS, and 2016 Ford Explorer vehicles manufactured on July 24, 2015. During vehicle production, the fuel tank attachment bolts may not have been properly tightened. As a result, the fuel tank straps may fracture and the fuel tank could separate from the vehicle.

    Consequence

    If the fuel tank separates from the vehicle, a fuel leak may occur, increasing the risk of a fire.

    What Owners Should Do

    Ford will notify owners, and dealers will tighten the fuel tank attachment bolts, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S26.

  • Recall Number
    01V171000
    Recall Date
    05/24/2001
    Component
    TIRES:SIDEWALL
    Summary

    VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.

    Consequence

    OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.

    What Owners Should Do

    DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

What Should You Do?

Contact your dealer as soon as possible
Every recall is serious, so it’s important that you contact an authorized service center as soon as possible to make an appointment to get it fixed.

Find Recalls for:

...More
Interested in learning more? Check out our Maintenance 101 tips or the terms glossary.
Research the Ford Explorer