2004 Chevrolet Monte Carlo Recalls
Search for recalls by car
Make selection is required
NHTSA safety recall results (3)
Recall information provided by National Highway Traffic Safety Administration
Component not known
04V287
Certain passenger vehicles were produced with lower than specified torque on both front brake calipers to steering knuckle attachment bolts. With improper torque, the clamp load at the joint may not be adequate to prevent movement between the caliper bracket and knuckle. Depending on whether one or both bolts backs out or fractures, the result can be locking of the affected wheel during braking and an abrupt steering input in the direction of the locked wheel, reduced braking and noise from the affected wheel, or severing of a brake hose, increased brake pedal travel, and reduced steering control. Reduced braking or steering control could cause a crash.
Dealers are to tighten both bolts to the specified torque. The manufacturer has reported that owner notification began on July 6, 2004. Owners may contact Chevrolet at 1-800-630-2438 or Pontiac at 1-800-620-7668.
View details Hide details
Engine and engine cooling
2015-10-26
15V701000
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. GM is finalizing an improved remedy. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number, once the improved remedy has been finalized. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
View details Hide details
Electrical system
2014-07-03
14V400000
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 6,729,742 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2005 Chevrolet Malibu, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will provide two replacement key rings and key cover on all ignition keys, free of charge. The manufacturer has not yet provided a notification schedule. GM's number for this recall is 14350.