Chevrolet Recalls

Make selection is required

NHTSA safety recall results (534)

Recall information provided by National Highway Traffic Safety Administration

Seat belts

General Motors LLC (GM) is recalling certain 2018-2019 Cadillac CT6, Escalade ESV, Chevrolet Suburban, Volt, and GMC Yukon XL vehicles. Certain second-row or third-row rear seatbelts retractor assemblies may not automatically lock when the seatbelt is fully pulled out of the retractor, possibly preventing a child seat from being properly secured. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Recall consequence: If the child seat is not properly secured in the event of a crash, it can increase the risk of injury.
Recall action: GM will notify owners, and dealers will inspect the rear seatbelt retractors and replace them if necessary, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18315.

Electrical system

General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Express and GMC Sierra vehicles equipped with a single, manual, rear climate control module (CCM). If the temperature is set to maximum heat or the mode knob is set to maximum floor vent and an electrical short occurs, components within the CCM may overheat.

Recall consequence: If the CCM overheats, there is an increased risk of a fire in the vehicle's headliner.
Recall action: GM will notify owners, and dealers will remove the electrical insulation from a wiring connector within the CCM to remove the fire risk, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18299.

Steering

General Motors LLC (GM) is recalling certain 2015 Chevrolet Silverado 1500, Tahoe and Suburban, GMC Sierra 1500 and Yukon, and Cadillac Escalade vehicles. Electric power steering (EPS) assist may be lost momentarily, followed by a sudden return of EPS assist.

Recall consequence: If EPS assist is lost and then suddenly returns, the driver may have difficulty steering the vehicle, especially at low speeds, increasing the risk of a crash.
Recall action: GM will notify owners, and dealers will update the EPS module software, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is 18289.

Service brakes, hydraulic

General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 2500, 3500, 1500 Crew Cab Special Service, Tahoe Police Pursuit/Special Service, GMC Sierra 2500, and 3500 vehicles. The brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.

Recall consequence: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Recall action: GM will notify owners, and dealers will add adhesive to the nut and reinstall the nut with increased tightness, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18278. Note: The vehicles in this recall need this additional remedy despite being covered by recall 16V069 for brake pedal loosening.

Service brakes, hydraulic

General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Equinox, Impala, Cruze, Volt and Bolt EV vehicles, GMC Terrain vehicles, Buick Lacrosse and Regal vehicles, Cadillac XTS and XTS Professional vehicles and 2018 Chevrolet Malibu vehicles. The rear brake caliper pistons may have an insufficient coating causing gas pockets to form, potentially reducing rear brake performance.

Recall consequence: A reduction of braking performance can increase the risk of a crash.
Recall action: GM will notify owners, and dealers will bleed the vehicle's brake system, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18279.

Tires

General Motors LLC (GM) is recalling certain 2018 Chevrolet Express and GMC Savana vehicles with certain combinations of front-tire and gross-vehicle-weight option codes. The Tire Pressure Monitoring System (TPMS) may be incorrectly calibrated, causing the TPMS warning lamp to illuminate when tire pressure reaches 37 PSI, not 41 PSI. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."

Recall consequence: If the low tire pressure telltale is not illuminated at the correct tire pressure, the driver may have less time to react to a low-tire-pressure situation, which could affect the driver's ability to control the vehicle in certain situations and could increase the risk of a crash.
Recall action: GM will notify owners, and dealers will check the PSI information on the remote control door lock receiver (RCDLR) and tire placard match, and if the information is different the RCDLR will be reprogrammed. This repair will be done free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18255.

Air bags

General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Malibu vehicles. During servicing, a Passenger Presence System (PPS) may have been installed that was not correctly calibrated to the vehicle's seat type. As a result, the PPS may not properly identify an adult passenger from a child passenger in the front passenger seat, potentially causing the air bag to not deploy when it should, or causing the air bag to deploy when it shouldn't.

Recall consequence: In the event of a crash, improper air bag deployment can increase the risk of injury.
Recall action: GM will notify owners, and dealers will replace the front passenger PPS seat service kit, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18208.

Hybrid propulsion system

General Motors LLC (GM) is recalling certain 2013 Chevrolet Volt vehicles. An update to the Hybrid Powertrain Control Module 2 (HPCM2) may have disabled the cell balancing function causing a low-voltage condition.

Recall consequence: If the voltage drops, the vehicle may lose propulsion, increasing the risk of crash.
Recall action: GM will notify owners, and dealers will reprogram the HPCM2, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18215.

Air bags

General Motors LLC (GM) is recalling certain 2019 Chevrolet Corvette ZR1 vehicles. Hard braking or acceleration may cause the sensing diagnostic module (SDM) to enter a fault state. As a result, the SDM will not provide crash sensing or deploy the necessary air bags in the event of a crash.

Recall consequence: In the event of a crash, if the air bags do not deploy as designed, the occupants have an increased risk of injury.
Recall action: GM will notify owners, and dealers will reprogram the SDM with updated software, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18195.

Fuel system, gasoline

General Motors LLC (GM) is recalling certain 2018 Buick LaCrosse, Cadillac ATS, Chevrolet Equinox, Malibu and Colorado and GMC Terrain, Acadia and Canyon vehicles. The high pressure fuel pump may detach from its mounting flange, possibly resulting in the pump damaging the high pressure fuel line.

Recall consequence: A damaged fuel line can create a fuel leak, increasing the risk of a fire.
Recall action: GM will notify owners, and dealers will replace the high pressure fuel pump, and high pressure fuel pipe, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18188.