Chevrolet Recalls

Make selection is required

NHTSA safety recall results (534)

Recall information provided by National Highway Traffic Safety Administration

Suspension

General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Corvette vehicles manufactured September 26, 2014, to October 2, 2014. In the affected vehicles the toe link outer ball joint on the rear suspension may not have been properly tightened during the assembly process. The Toe link may loosen with the vehicle use and eventually separate.

Recall consequence: A toe link separation can result in a reduction in vehicle stability and steering control, increasing the risk of a vehicle crash.
Recall action: GM will notify owners, and dealers will inspect and replace any damaged parts, free of charge. The recall began February 23, 2015. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet). GM's number for this recall is 14857.

Electrical system

General Motors LLC (GM) is recalling certain model year 2011-2012 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado HD, Silverado LD, Suburban, Tahoe, GMC Sierra LD, Sierra HD, Yukon, and Yukon XL vehicles. In the affected vehicles, the ignition lock actuator may bind, making turning the key difficult or causing the ignition to get stuck in the "Start" position.

Recall consequence: If stuck in the "Start" position, the ignition may suddenly snap back into the "Accessory" position, causing a loss of engine, steering, and braking power, increasing the risk of a vehicle crash. If the vehicle is in a crash, the air bags may not deploy, increasing the risk of occupant injury.
Recall action: GM will notify owners, and dealers will inspect and replace the ignition lock housing, as necessary, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact GM customer service at 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14696 for the original equipment, and 14912 for the service replacement parts.

Fuel system, diesel

General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado HD diesel vehicles manufactured September 30, 2014, to October 21, 2014, and GMC Sierra HD diesel vehicles manufactured October 8, 2014, to October 21, 2014. In the affected vehicles, the hose clamp that secures the fuel tank vent line may not have been properly tightened during assembly.

Recall consequence: A loose hose clamp could allow the fuel tank vent line to detach which may result in a fuel leak, increasing the risk of a fire.
Recall action: GM will notify owners, and dealers will inspect and tighten the fuel tank vent line hose clamp, as necessary, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14855.

Power train

General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado 1500, and GMC Sierra 1500 vehicles manufactured November 24, 2014, to November 25, 2014. Due to an improper heat-treatment, the rear axle shaft may fracture while the vehicle is being driven.

Recall consequence: If the rear axle shaft fractures, the rear wheel may separate from the axle shaft, increasing the risk of a crash.
Recall action: GM will notify owners, and dealers will inspect the rear axles, and replace any that were improperly heat-treated, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet) or 1-800-462-8782 (GMC). GM's number for this recall is 14892.

Steering

General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado, Suburban, Tahoe, GMC Sierra, and Yukon XL vehicles, equipped with electric power steering (EPS). Due to a problem with the EPS module, the affected vehicles may experience a sudden loss of power steering assist during vehicle operation.

Recall consequence: An expected loss of power steering increases the risk of a crash.
Recall action: GM will notify owners, and dealers will replace the power steering assist motor kit, free of charge. The recall began on November 17, 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14743.

Air bags

General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Colorado and GMC Canyon vehicles manufactured January 6, 2014, to October 1, 2014. In the affected vehicles, the driver air bag connections may have been wired incorrectly. This could reverse the deployment sequence and disrupt the deployment timing of the driver air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 208, "Occupant Crash Protection."

Recall consequence: If the driver air bag does not deploy as designed, there is an increased risk of driver injury in the event of a crash necessitating air bag deployment.
Recall action: GM will notify owners, and dealers will reprogram the inflatable restraint sensing and diagnostic module (SDM), free of charge. The recall began on October 6, 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet) or 1-800-462-8782 (GMC). GM's number for this recall is 14690.

Component not known

General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.

Recall consequence: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.
Recall action: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM's number for this recall is 14515.

Component not known

General Motors LLC (GM) is recalling certain model year 2013-2015 Chevrolet Spark vehicles manufactured January 17, 2012, to July 29, 2014. The secondary hood latch may prematurely corrode at the latch pivot causing the striker to get stuck out of position, preventing it from properly engaging the hood latch.

Recall consequence: If the secondary hood latch corrodes causing the latch to be stuck out of position, and the primary hood latch is not engaged, the hood could unexpectedly open while driving, increasing the risk of a vehicle crash.
Recall action: GM will notify owners, and dealers will replace the striker and latch with a new part which has superior corrosion protection, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14456.

Air bags

General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Corvette vehicles manufactured August 20, 2014, to August 27, 2014. In the event of a driver frontal air bag deployment, the driver air bag module back plate may fracture, allowing the driver air bag to separate from the steering wheel.

Recall consequence: An air bag that separates from the steering wheel may increase the risk of injury to the driver in the event of a crash.
Recall action: GM will notify owners, and dealers will replace the driver side air bag, free of charge. The recall began on October 29, 2014. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14594.

Parking brake

General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Corvette vehicles manufactured August 20, 2014, to September 4, 2014. In the affected vehicles, only one of the rear parking brake cables may be fully seated and engaged, resulting in the parking brake only operating on one of the rear park brake drums. Without the parking brake working on both rear wheels, the vehicle may roll away if parked on a steep gradient. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 135, "Light Vehicle Brake Systems."

Recall consequence: If the parking brake cable isn't fully seated and engaged on both of the rear park brake drums, the vehicle may roll away if parked on a steep gradient, increasing the risk of a crash.
Recall action: GM will notify owners, and dealers will inspect and correct the park brake cable installation, as necessary, free of charge. The recall began on October 31, 2014. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14620.