Chevrolet Recalls

Make selection is required

NHTSA safety recall results (534)

Recall information provided by National Highway Traffic Safety Administration

Fuel system, gasoline

GM IS RECALLING 27,188 MY 2009 CADILLAC ESCALADE, ESCALADE HYBRID, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SUBURBAN, TAHOE, TAHOE HYBRID, AND COLORADO; AND GMC YUKON, YUKON HYBRID, YUKON XL, AND CANYON VEHICLES. THE FUEL SYSTEM CONTROL MODULES MAY HAVE A CONDITION IN WHICH AN ADHESIVE SEPARATION OF THE ROOM TEMPERATURE VULCANIZING (RTV) SEAL BETWEEN THE SEAL AND THE HOUSING MAY ALLOW WATER TO SEEP INTO THE MODULE.

Recall consequence: WATER IN THE MODULE COULD CAUSE A SHORT OR OPEN CIRCUIT, ILLUMINATION OF THE SERVICE ENGINE SOON LAMP, SETTING OF DIAGNOSTIC TROUBLE CODES OR THE ENGINE MAY BE HARD TO START, MAY NOT START OR MAY STALL INCREASING THE RISK OF A CRASH.
Recall action: DEALERS WILL INSTALL A NEW FUEL SYSTEM CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MAY 18, 2009. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.

Parking brake

GM IS RECALLING 15,393 MY 2009 CHEVROLET TRAVERSE VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKE SYSTEMS." THESE VEHICLES MAY HAVE A PARK BRAKE CABLE LINK (CONNECTOR) THAT IS NOT TO SPECIFICATION. THIS CONNECTOR MAY FRACTURE WHEN THE PARK BRAKE PEDAL IS DEPRESSED.

Recall consequence: IF THE TRANSMISSION SHIFT LEVER IS IN THE PARK POSITION, THERE WILL BE NO UNINTENDED VEHICLE MOVEMENT. HOWEVER, IF THE KEYS ARE LEFT IN THE IGNITION, THE TRANSMISSION SHIFT LEVER IS IN ANY POSITION OTHER THAN PARK, AND THE VEHICLE IS PARKED ON A SUFFICIENT SLOPE, IT COULD RESULT IN UNINTENDED VEHICLE MOVEMENT. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.
Recall action: DEALERS ARE TO REPLACE THE PARK BRAKE CABLE LINK (CONNECTOR) FREE OF CHARGE. GM ANTICIPATES THAT THE DEALER BULLETIN WILL BE SENT MAY 5, 2009 AND OWNER LETTERS WILL BE MAILED IN JUNE 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OR AT WWW.GMOWNERCENTER.COM.

Electrical system: Battery: Cables

LDV IS RECALLING 81 TRUCKS BUILT ON CHEVY AND FORD MY 2007-2009 C5500, MY 2008-2009 W5500, AND MY 2008 F-650 CHASSIS SPECIFICALLY FOR SNAP-ON TOOLS FOR USE AS A MOBILE SUPPLY COMPANY. THERE MAY BE A CABLE INSTALLED ON THE BATTERY ISOLATOR WITH THE BODY OF THE CABLE LUG FACING THE ISOLATOR. WITH ALL CABLES TIGHTENED DOWN ON THE STUD, THIS CABLE LUG MAY BE PRESSED AGAINST THE COOLING FINS OF THE ISOLATOR, WHERE CONTACT (WHICH CABLE INSULATION HAS BEEN WORN THROUGH) POSES A RISK OF ELECTRICAL SHORT WHICH COULD RESULT IN CABLES OVERHEATING.

Recall consequence: THIS CONTACT POSES A RISK OF ELECTRICAL SHORT WHICH COULD RESULT IN CABLES OVERHEATING AND A FIRE COULD OCCUR.
Recall action: DEALERS WILL TAKE A TWO-STEP REMEDY. THE FIRST STEP IS TO INSPECT THE CABLE INSTALLATION TO ENSURE ALL CABLES ARE INSTALLED WITH THE LUG BODY FACING AWAY FROM THE ISOLATOR WITH NONE IN CONTACT WITH THE COOLING FINS. SECOND STEP INVOLVES ADDING A GROUNDING STRAP OR ABLE TO HE ALUMINUM BOX TO PROPERLY GROUND IT AND THE COMPONENTS MOUNTED WITHIN IT. THE RECALL IS EXPECTED TO BEGIN APRIL 15, 2009. OWNERS MAY CONTACT LDV AT 608-257-3911.

Power train: Automatic transmission: Lever and linkage: Column shift

GENERAL MOTORS IS RECALLING 276, 729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".

Recall consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Recall action: DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.

Steering

DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONSTM " BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.

Recall consequence: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Recall action: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 20, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492.

Power train: Driveline: Driveshaft

IZUSU IS RECALLING 2,836 MY 2008-2009 NPR/NQR AND NRR, GMC W3500, 4500 AND 5500, CHEVROLET W3500, 4500 AND 5500 TRUCKS. THE PROPELLER SHAFT WAS MANUFACTURED WITH INSUFFICIENT HIGH FREQUENCY HEAT TREATMENT. AS A RESULT, THE AFFECTED PORTION OF THE PROPELLER SHAFT MAY NOT MAINTAIN ITS DURABILITY THROUGH THE EXPECTED VEHICLE USEFUL LIFE.

Recall consequence: THE PROPELLER SHAFT COULD BREAK OFF WHILE THE VEHICLE IS BEING DRIVING, WHICH WOULD RESULT IN THE VEHICLE STALLING AND COASTING TO A STOP, OR LOSS OF VEHICLE CONTROL WHICH COULD RESULT IN A CRASH.
Recall action: DEALERS WILL REPLACE THE PROPELLER SHAFT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 5, 2009. OWNERS MAY CONTACT ISUZU AT 1-866-441-9638.

Visibility: Defroster/defogger system

GM IS RECALLING 77 MY 2009 CHEVROLET MALIBU HYBRID VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEM." THE HEATING, VENTILATION, AND AIRCONDITIONING (HVAC) SYSTEM MAY BECOME INOPERATIVE. IF THIS WERE TO OCCUR, THE BLOWER WOULD NOT FUNCTION PROPERLY AND THE MODE SELECTOR WOULD REMAIN IN THE LAST KNOWN SETTING.

Recall consequence: IF THE WINDSHIELD BEGAN TO FOG OR FROST, THERE MAY NOT BE ENOUGH AIRFLOW TO CLEAR THE WINDSHIELD, RESULTING IN REDUCED DRIVER VISIBILITY AND A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Recall action: DEALERS WILL REPROGRAM THE HVAC CONTROL HEAD MODULE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT WWW.GMOWNERCENTER.COM.

Equipment adaptive

SUNSET VANS IS RECALLING 169 MY 2005-2007 ECONOLINE, G SERIES AND SPRINTER TRUCKS BUILT ON DODGE, FORD AND CHEVROLET CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES. THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Recall consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Recall action: SUNSET VANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR SUNSET VANS AT 1-888-280-8267.

Equipment adaptive

SUNSET VANS IS RECALLING 267 MY 2005-2007 ECONOLINE, G SERIES AND SPRINTER TRUCKS BUILT ON DODGE, FORD AND CHEVROLET CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Recall consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Recall action: SUNSET VANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR SUNSET VANS AT 1-888-280-8267.

Equipment adaptive

CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Recall consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Recall action: CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.