Chevrolet Recalls

Make selection is required

NHTSA safety recall results (535)

Recall information provided by National Highway Traffic Safety Administration

Fuel system, other

Isuzu Motors Limited (Isuzu) is recalling certain 2022-2026 Isuzu FVR, Isuzu FTR, Chevrolet 6500XD, and 2023-2026 Chevrolet 7500XD vehicles. The fuel heater may overheat, melting the casing and allowing fuel to leak into the electrical connector.

Recall consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Recall action: Dealers will inspect and replace the fuel heater and electrical connectors as necessary, free of charge. Owner notification letters were mailed November 7, 2025. Owners may contact Isuzu customer service at 1-866-441-9638. Isuzu's number for this recall is V2504.

Fuel system, diesel

General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.

Recall consequence: A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Recall action: Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.

Electronic stability control light may not illuminate/fmvss 126

General Motors, LLC (GM) is recalling certain 2026 Chevrolet Silverado EV and GMC Sierra EV electric vehicles. After experiencing an electronic stability control (ESC) system malfunction, the ESC malfunction warning light may not illuminate on the next key cycle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."

Recall consequence: An indicator light that does not illuminate may fail to warn the driver of an ESC system issue, increasing the risk of a crash.
Recall action: The EBCM software will be updated by a dealer, or through an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed October 15, 2025. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252515340.

Fuel system, gasoline

General Motors, LLC (GM) is recalling certain 2023?2026 Chevrolet Corvette vehicles equipped with a left-side radiator/fan combination. Excess fuel may spill into the vehicle fuel-filler pocket during refueling and leak onto an ignition source.

Recall consequence: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Recall action: Dealers will install a shield to divert spilled fuel, free of charge. Owner notification letters were mailed November 14, 2025. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252514930.

Parking brake

General Motors, LLC (GM) is recalling certain 2024-2025 Chevrolet Blazer EV vehicles. The rear parking brake wiring harness may become damaged or corroded, resulting in unintended activation of the parking brake or loss of the parking brake function.

Recall consequence: Unintended activation of the parking brake while driving increases the risk of a crash. Loss of the parking brake function while parked can result in a rollaway, increasing the risk of a crash.
Recall action: Dealers will inspect the harness and, if necessary, reroute the harness and install anti-abrasive tape. Any harness that has existing damage will be replaced. Repairs will be performed free of charge. Owner notification letters are expected to be mailed on August 11, 2025. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252503010.

Air bags

General Motors (GM) is recalling certain 2018 GMC Sierra 1500, 2019 Sierra 2500, 3500, Chevrolet Silverado 3500, and Chevrolet Silverado 2500 and 2018 Chevrolet Silverado 1500 Crew Cab vehicles. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.

Recall consequence: A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increases the risk of injury or crash.
Recall action: Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters are expected to be mailed August 11, 2025. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252513060.

Service brakes, hydraulic

General Motors (GM) is recalling certain 2019-2024 Chevrolet Silverado Medium Duty 4500HD, 5500HD, and 6500HD vehicles. The brake pressure sensor assembly may leak brake fluid into the brake pressure switch and cause a short circuit.

Recall consequence: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.
Recall action: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch wire harness, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed July 28, 2025. Second letters will be mailed once the remedy is available. Owners may contact GM customer assistance number at 1-866-467-9700. GM's number for this recall is N242482680. Vehicles in this recall that were previously repaired under 23V266 will need to have the new remedy completed.

Seats

General Motors LLC (GM) is recalling certain 2025 Chevrolet Express and GMC Savana vehicles. The front passenger seat head restraint may have been improperly welded to the seat frame.

Recall consequence: An improperly welded head restraint can result in an increased risk of injury to the seat occupant during a crash.
Recall action: Dealers will inspect and replace the front passenger seat frame, as necessary, free of charge. Owner notification letters are expected to be mailed June 23, 2025. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N252503580.

Engine and engine cooling

General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.

Recall consequence: Engine failure increases the risk of a crash.
Recall action: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install a new oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters are expected to be mailed June 9, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.

Steering

General Motors LLC (GM) is recalling certain 2016-2018 Cadillac CTS, 2017-2018 Cadillac ATS, Chevrolet Camaro, and Chevrolet Corvette vehicles. The electric power steering (EPS) assist may fail.

Recall consequence: A loss of power steering assist can require greater steering effort, especially at low speeds, increasing the risk of a crash.
Recall action: Dealers will replace the power steering gear assembly, free of charge. Owner notification letters were mailed April 15, 2025. Owners may contact Cadilac customer service at 1-800-333-4223 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252497020.