Ford Recalls
Search for recalls by car
Make selection is required
NHTSA safety recall results (704)
Recall information provided by National Highway Traffic Safety Administration
Steering: Linkages: Knuckle: Spindle: Arm
2024-02-07
24V091000
Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles. The right-front lower fastener connecting the steering knuckle and strut may be loose or missing.
A loose or missing connection between the knuckle and strut can cause improper tire alignment, resulting in a steering pull or require increased steering effort. Additionally, the brake hose may contact the tire and become damaged, resulting in a brake fluid leak and a loss of braking ability. Either of these scenarios can increase the risk of a crash.
Dealers will inspect the fasteners, and tighten or install them as necessary, free of charge. Owner notification letters were mailed March 08, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S04.
View details Hide details
Structure: Body: Roof and pillars
2024-01-18
24V031000
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Dealers will inspect and replace the A-pillar trim as necessary, free of charge. Owner notification letters were mailed on July 18, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
View details Hide details
Power train: Axle hubs
2023-12-21
23V896000
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with the Trailer Tow Max Duty package and a 9.75-inch heavy duty axle with a 3/4 float axle design. The rear axle hub bolt may fatigue and break, which can result in damage to the axle hub splines.
Damaged axle hub splines can result in a vehicle rollaway when the vehicle is in park without the parking brake applied or cause a loss of drive power. Both of these conditions can increase the risk of a crash.
Dealers will replace the left and right rear axle shaft assemblies, free of charge. Interim owner notification letters explaining the safety risk were mailed January 29, 2024 and again on June 12, 2024. A second notice will be sent once remedy parts become available, anticipated 1st Quarter 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S65.
View details Hide details
Engine and engine cooling: Engine: Oil/lubrication: Pump
2023-12-21
23V905000
Ford Motor Company (Ford) is recalling certain 2016-2018 Ford Focus and 2018-2022 Ford EcoSport vehicles. The oil pump drive belt or drive belt tensioner may fail, resulting in a loss of engine oil pressure.
A loss of oil pressure can result in an engine stall and a loss of power braking assist, increasing the risk of a crash.
Dealers will replace the oil pump tensioner assembly and oil pump drive belt, free of charge. If engine failure occurs due to a damaged oil pump belt and/or oil pump belt tensioner, Ford has authorized dealers to replace the engine assembly as an interim repair before the availability of remedy parts for the final repair. This repair will be free of charge (parts and labor). Interim owner notification letters explaining the safety risk were mailed June 20, 2024. A second notice will be sent once remedy parts become available, anticipated in 4th Quarter 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S64.
View details Hide details
Steering: Column
2023-12-14
23V847000
Ford Motor Company (Ford) is recalling certain 2023 F-150 and Ford SD F250, F350, F450, F550, and F600 vehicles. The steering wheel clock spring may have an insufficient weld, causing a loss of electrical connection to the driver's frontal air bag.
A deactivated air bag will not deploy during a crash, increasing the risk of injury.
Dealers will inspect and replace the clock spring as necessary, free of charge. Owner notification letters were mailed on May 3, 2024. Owners may contact Ford customer service at 1-866-436-7332.
View details Hide details
Service brakes, hydraulic: Pedals and linkages
2023-11-27
23V800000
Ford Motor Company (Ford) is recalling certain 2024 Mustang vehicles. The brake pedal assembly may have been manufactured incorrectly, which can result in a loose brake pedal.
A loose brake pedal can result in a loss of braking function, increasing the risk of a crash.
Owners are advised not to drive their vehicle until the repair has been performed. Dealers will replace the brake pedal and bracket assembly, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S61.
View details Hide details
Electronic stability control (esc)
2023-11-27
23V801000
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning vehicles. The SYNC software may fail to activate the electronic stability control (ESC) system at the beginning of each ignition cycle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Failure to reset the ESC to active may result in the driver unknowingly operating the vehicle without electronic stability control, increasing the risk of a crash.
The Accessory Protocol Interface Module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C38.
View details Hide details
Exterior lighting: Lighting control module
2023-11-27
23V802000
Ford Motor Company (Ford) is recalling certain 2022 F-150 vehicles. The parking lights may flicker when the headlights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Flickering parking lights can reduce visibility, increasing the risk of a crash.
Dealers will update the LED driver module software, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C36. Vehicles with high series headlamps previously recalled under recall number 22V-686 that received an incomplete remedy, or have not yet been repaired, will need to have the new remedy completed.
View details Hide details
Latches/locks/linkages: Doors: Latch
2023-11-16
23V775000
Ford Motor Company (Ford) is recalling certain 2015 Fiesta, 2016 Fusion, and 2016 Lincoln MKZ vehicles sold, or ever registered in Alabama, Arkansas, Arizona, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, New Mexico, Nevada, Oklahoma, Oregon, South Carolina, Texas, Utah, Washington, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. A component inside the door latches may break, which can make it difficult to latch or possibly allow the doors to open while driving.
Vehicle doors opening unexpectedly while driving can increase the risk of a crash or injury.
Dealers will inspect the door latch date codes and if necessary, replace all four side door latches, free of charge. Owner notification letters were mailed December 20, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S15. This recall is an expansion of NHTSA recall number 20V-177.
View details Hide details
Power train: Axle hubs
2023-11-08
23V758000
Ford Motor Company is recalling certain 2022-2023 Ford Super Duty F-350, F-450, F-550, and F-600 vehicles. The fasteners for the front wheel hub extender may be insufficiently tightened, which can result in the wheel and wheel extender detaching from the vehicle.
Wheel detachment can result in a loss of vehicle control and create a road hazard, increasing the risk of a crash.
Owners are advised not to drive their vehicle until the repair has been performed. Dealers will inspect the front wheel hub extender retaining nuts. If the retaining nuts are loose, dealers will replace the wheel hub extender, retaining nuts, and hub assembly. Repairs will be performed free of charge. Owner notification letters were mailed December 7, 2023. Owners may contact Ford customer service at -866-436-7332. Ford's number for this recall is 23S59.