2012 Hyundai SONATA Recalls

Make selection is required

NHTSA safety recall results (9)

Recall information provided by National Highway Traffic Safety Administration

Equipment

Hyundai Motor America (Hyundai) is recalling certain 2011-2012 Hyundai Elantra and Sonata Hybrid, 2012 Accent and Veloster vehicles. The 12V accessory socket outlet may have been over-tightened during installation, possibly disabling the thermal fuse and allowing the outlet to overheat with prolonged use, such as by using the Tire Mobility Kit air compressor to inflate a tire.

Recall consequence: An overheated accessory outlet increases the risk of fire.
Recall action: Hyundai is currently developing a remedy. The remedy procedure will be performed free of charge. The recall is expected to begin August 28, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 193.

Fuel system, gasoline: Delivery: Hoses, lines/piping, and fittings

Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2013-2014 Santa Fe Sport vehicles previously repaired under recall numbers 15V-568 and 17V-226. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned, or improperly torqued during the engine replacement procedure, allowing fuel to leak from the pipe.

Recall consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Recall action: Hyundai will notify owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began March 1, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's recall number for this recall is 180.

Seat belts: Front: Anchorage

Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. The seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.

Recall consequence: If the seat belt linkage detaches from the seat belt anchorage, it can not properly restrain the occupant in the event of a crash, increasing the risk of injury.
Recall action: Hyundai will notify owners, and dealers will again verify the connection between the seat belt linkage and the pretensioner and additionally install a warning label to prevent future seat belt linkage detachment, free of charge. The recall began November 6, 2017. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 169.

Seat belts: Front: Anchorage

Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. In the affected vehicles, the seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.

Recall consequence: In the event of a crash, if the seat belts detach from the anchor pretensioners, it can increase the risk of injury.
Recall action: Hyundai will notify owners and dealers will inspect the connection between the seat belt linkages and the seat belt anchor pretensioners, repairing them as necessary, free of charge. The recall is expected to begin April 7, 2017. Owner's may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for the recall is 160.

Service brakes, hydraulic

Hyundai Motor America (Hyundai) is recalling certain model 2011-2012 Sonata vehicles. The brake pedal stopper pad can deteriorate allowing the brake light switch plunger to remain extended when the brake pedal is released.

Recall consequence: If the brake light switch plunger does not retract as it should when the brake pedal is not being pressed, the brake lights may stay illuminated preventing accurate communication to rearward following vehicles that the vehicle is slowing or stopping. Additionally, if the brake switch plunger is not retracted, then the transmission can be shifted out of PARK without depressing the brake pedal. Either condition increases the risk of a crash.
Recall action: charge. The recall is expected to begin on January 11, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 136.

Engine

Hyundai Motor America (Hyundai) is recalling certain model year 2011-2012 Sonata vehicles manufactured December 11, 2009, to April 12, 2012 at Hyundai Motor Manufacturing Alabama and equipped with either a 2.0 liter or 2.4 liter Gasoline Direct injection engine. In the affected vehicles, metallic debris may not have been fully removed during manufacturing of the engine crankshaft. If the debris was not completely removed, oil flow may be restricted through the connecting rod bearings, causing connecting rod damage. A worn connecting rod bearing will produce a metallic, cyclic knocking noise from the engine and possible engine failure.

Recall consequence: Engine failure would result in a vehicle stall, increasing the risk of a crash.
Recall action: Hyundai will notify owners, and dealers will inspect the vehicles and replace the engine assembly, as necessary, free of charge. Additionally, Hyundai Motor America will increase the warranty for the engine sub-assembly (short block) to 10 years/120,000 miles for both original and subsequent owners of 2011 and 2012 Sonatas manufactured at Hyundai Motor Manufacturing Alabama equipped with 2.0 liter and 2.4 liter Gasoline Direct injection engines. An interim notification will be mailed by November 2, 2015. A second notification will be mailed when parts are available. Owners may contact Hyundai customer service at 1-855-671-3059 or by visiting www.HyundaiUSA.com/Campaign132. Hyundai's number for this recall is 132.

Component not known

Hyundai Motor Company (Hyundai) is recalling certain model year 2011-2014 Sonata vehicles manufactured December 11, 2009, through May 29, 2014. In the affected vehicles, the transmission shift cable may detach from from the shift lever pin.

Recall consequence: If the transmission shift cable detaches, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver parks the vehicle, despite selecting the 'PARK' position, the transmission may not be in 'PARK.' If the vehicle is not in the 'PARK' position and the parking brake is not applied, there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Recall action: Hyundai will notify owners, and dealers will inspect and, as necessary, repair the connection between the shift cable and shift lever, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 123.

Air bags: Side/window

Hyundai is recalling certain model year 2012-2013 Hyundai Sonata passenger cars, manufactured from January 24, 2012, through June 21, 2012. The curtain side airbags on these vehicles may inflate without deployment command due to an error during manufacturing.

Recall consequence: The curtain airbag may inflate without deployment command and increase the risk of injury to occupants of the vehicle. Additionally, an unexpected deployment would be a significant driver distraction and would limit the driver's visibility, increasing the risk of a crash.
Recall action: Hyundai dealers will notify owners, and dealers will replace the curtain side airbags free of charge. This recall is expected to begin during August 2012. Owners may contact Hyundai at 1-800-633-5151.

Seat belts: Rear

CERTAIN MODEL YEAR HYUNDAI SONATA HYBRID VEHICLES PRODUCED BEGINNING ON DECEMBER 2, 2010, AND SHIPPED TO DEALERS THROUGH MARCH 7, 2012, THAT ARE EQUIPPED WITH A CENTER REAR SEAT BELT INCORPORATING A RELEASE MECHANISM THAT DETACHES BOTH THE LAP AND SHOULDER PORTION AT THE LOWER ANCHORAGE POINT, FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION."

Recall consequence: SEE NOTES.
Recall action: DEALERS WERE NOTIFIED OF THE NONCOMPLAINCE AND A STOP SALE WAS ISSUED ON MARCH 8, 2012.