Toyota Corolla Recalls

Make selection is required

NHTSA safety recall results (48)

Recall information provided by National Highway Traffic Safety Administration

Visibility: Power window devices and controls

Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.

Recall consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Recall action: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.

Structure: Body: Roof and pillars

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010-2011 COROLLA VEHICLES EQUIPPED WITH A NON-TOYOTA, BLUE TOOTH HANDS FREE DEVICE OR NAVIGATION UNIT AND CERTAIN MODEL YEAR 2011 TOYOTA SIENNA VEHICLES EQUIPPED WITH A NON-TOYOTA, OVERHEAD ENTERTAINMENT SYSTEM AND/OR BLUETOOTH HANDS FREE DEVICE. THERE IS A POSSIBILITY THAT THE FRONT A-PILLAR TRIM PANEL RETENTION CLIP MAY HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE AFTERMARKET ACCESSORY.

Recall consequence: A DAMAGED A-PILLAR TRIM PANEL RETENTION CLIP MAY ALLOW THE TRIM PANEL TO COME LOOSE AND INJURE AN OCCUPANT IN THE EVENT OF A CRASH.
Recall action: DEALERS WILL INSPECT THE A-PILLAR TRIM PANEL RETENTION CLIP AND REPLACE IT IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Engine and engine cooling

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2008 COROLLA AND COROLLA MATRIX VEHICLES. THE ENGINE CONTROL MODULE (ECM) FOR THE SUBJECT MODELS EQUIPPED WITH THE 1ZZ-FE ENGINE AND TWO-WHEEL DRIVE MAY HAVE BEEN IMPROPERLY MANUFACTURED. THERE IS A POSSIBILITY THAT A CRACK MAY DEVELOP AT CERTAIN SOLDER POINTS OR ON VARISTORS ON THE CIRCUIT BOARD.

Recall consequence: HARSH SHIFTING COULD RESULT, THE ENGINE MAY NOT START, OR THE ENGINE COULD STOP RUNNING WHILE THE VEHICLE IS BEING DRIVEN INCREASING THE RISK OF A CRASH.
Recall action: DEALERS WILL INSPECT THE PRODUCTION NUMBER OF THE ECM AND REPLACE THE ECM IF NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. TOYOTA WILL MAIL AN INTERIM OWNER NOTIFICATION THE MIDDLE OF SEPTEMBER 2010 TO ADVISE OWNERS OF THIS DEFECT AND RECALL. THIS INTERIM NOTIFICATION WILL INFORM OWNERS THAT THEY WILL RECEIVE A FUTURE NOTIFICATION WHEN PARTS BECOME AVAILABLE TO HAVE THE FREE REMEDY PERFORMED ON THEIR VEHICLE. A SCHEDULE HAS NOT BEEN SET FOR THE FUTURE NOTIFICATIONS. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Equipment: Other: Labels

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Recall consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Recall action: DEALERS WILL REPLACE THE CERTIFICATION LABEL, THE TIRE AND LOADING INFORMATION LABEL, AND THE LOAD CARRYING CAPACITY MODIFICATION (ADDENDUM) LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Equipment: Other: Labels

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006-2009 SIENNA PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Recall consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Recall action: DEALERS WILL REPLACE THE LOAD CARRYING CAPACITY MODIFICATION (ADDENDUM) LABEL FREE OF CHARGE. THE RECALL EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-954-420-2000.

Service brakes, hydraulic: Power assist: Vacuum

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2009 SCION XD AND MY 2009-2010 COROLLA, COROLLA MATRIX AND PONTIAC VIBE VEHICLES EQUIPPED WITH 1.8L ENGINE AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, IDAHO, ILLINOIS IOWA, KANSAS, MAINE, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WHEN DRIVING UNDER CERTAIN UNIQUE CONDITIONS IN EXTREMELY LOW AMBIENT TEMPERATURES, THE INTAKE MANIFOLD SUCTION PORT FOR THE BRAKE VACUUM CAN BECOME LOCKED DUE TO THE FREEZING OF CONDENSATION RESULTING FROM POSITIVE CRANKCASE VENTILATION.

Recall consequence: THIS COULD LEAD TO AN INCREASE IN VEHICLE STOPPING DISTANCE AND A CRASH COULD OCCUR.
Recall action: DEALERS WILL INSTALL A NEWLY DESIGNED INTAKE AIR CONNECTOR WHICH WILL RELOCATE THE BRAKE SYSTEM VACUUM PORT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE SEPTEMBER 15, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Equipment: Other: Labels

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 COROLLA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE AIR BAG LABEL INSTALLED ON THE DRIVER SIDE SUN VISOR CAN SEPARATE FROM THE SURFACE OF THE VISOR.

Recall consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Recall action: DEALERS WILL INSPECT THE LABEL AND EXCHANGE THE DRIVER'S SIDE SUN VISOR FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE OCTOBER 15, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Wheels

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH FACTORY ALUMINUM ALLOY WHEELS, THE LUG NUT(S) MAY NOT SECURE THE WHEEL PROPERLY TO THE HUB ASSEMBLY DUE TO OVER-DRILLING OF ONE OR MORE OF THE FIVE LUG NUT HOLES ON THE ALLOY WHEEL. IF THE VEHICLE IS DRIVEN FOR AN EXTENDED PERIOD IN THIS CONDITION, THE LUG NUT(S) COULD POTENTIALLY LOOSEN.

Recall consequence: IN THE WORST CASE, THE STUD BOLT(S) MAY FRACTURE, WHICH MAY RESULT IN THE SEPARATION OF THE WHEEL FROM THE HUB ASSEMBLY AND LEAD TO A LOSS OF VEHICLE CONTROL.
Recall action: DEALERS WILL INSPECT ALL FOUR FACTORY ALUMINUM ALLOY WHEELS AND, IF NECESSARY, REPLACE ANY FOUND TO BE OUT OF SPECIFICATIONS. OWNER NOTIFICATION BEGAN OCTOBER 27, 2003. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.