Volvo XC40 Recalls
Search for recalls by car
Make selection is required
NHTSA safety recall results (11)
Recall information provided by National Highway Traffic Safety Administration
Electrical system: Software
2024-01-09
24V010000
Volvo Car USA, LLC (Volvo Car) is recalling certain 2024 XC40 vehicles. A diagnostic error in the Central Electronic Module (CEM) software may cause the left rear turn signal indicator to not function.
A nonfunctioning exterior turn signal may not notify other drivers of a turning vehicle, increasing the risk of a crash.
The CEM software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed February 16, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10256.
View details Hide details
Electrical system
2023-03-21
23V188000
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 S60, V60CC, XC60, XC90, XC40, and C40 vehicles. A diagnostic trouble code (DTC) may be falsely detected for the emergency call system (e-call) and display "e-Call Service Required" in the driver information module (DIM).
The false warning message could prevent the detection of an actual e-call system failure, which could delay an emergency response during a crash, increasing the risk of injury.
Dealers will update the telematics and connectivity antenna module (TCAM) software, free of charge. Owner notification letters are expected to be mailed May 16, 2023. Owners may contact Volvo Car's customer service 1-800-458-1552. Volvo Car's number for this recall is R10225.
View details Hide details
Service brakes, hydraulic
2023-01-18
23V012000
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 S60, V60, V60CC, V90CC, XC60, XC90, XC40, and C40 vehicles. A diagnostic error in the Brake Control Module 2 (BCM2) may cause a loss of Antilock Brake System (ABS), Electronic Stability Control (ESC), and traction control.
A reduction in brake support functions can increase the risk of a crash.
Volvo will release an over-the-air (OTA) BCM2 software update, free of charge. Owner notification letters are expected to be mailed March 15, 2023. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10217.
View details Hide details
Vehicle speed control: Accelerator pedal
2022-04-27
22V288000
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2022 XC40 BEV vehicles. Water may enter the cable harness, corroding the accelerator pedal sensor (APS) circuit.
A corroded APS circuit may send corrupted signals, causing unintended acceleration, a lack of acceleration, or a loss of drive power, increasing the risk of a crash.
Dealers will inspect for corrosion, install a cable splice to prevent water intrusion and, as necessary, replace the connector terminal and APS, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Volvo Car at 1-800-458-1552. Volvo Car's number for this recall is R10170.
View details Hide details
Structure: Frame and members
2021-11-11
21V881000
Volvo Car USA, LLC (Volvo) is recalling certain 2021 XC40 BEV vehicles. A bolt that secures the cross-member bracket for the electrical motor in the engine compartment may be loose or missing.
A loose or missing bolt may decrease the structural protection of the vehicle, increasing the risk of injury during a crash.
Dealers will replace the cross-member bracket and install new bracket bolts, free of charge. Owner notification letters were mailed December 16, 2021. Owners may contact Volvo customer service at 1-888-458-1552. Volvo's number for this recall is R10128.
View details Hide details
Seat belts
2021-08-31
21V682000
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
An unsecured child restraint system can increase the risk of injury during a crash.
Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10111.
View details Hide details
Electrical system: Propulsion system: Traction battery: Management system/energy control module (bms/becm): Software
2021-02-23
21V109000
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2022 XC40 Recharge vehicles. The Battery Energy Control Module (BECM) microprocessor may reset and cause the high voltage system to disconnect.
A disconnected high voltage system can cause a loss of drive power, increasing the risk of a crash.
Volvo Car will notify owners, and dealers will install a software update, free of charge. The recall began March 30, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10078.
View details Hide details
Forward collision avoidance: automatic emergency braking
2020-03-11
20V144000
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
View details Hide details
Electrical system: Software
2018-11-12
18V800000
Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
If the GPS location is not provided to emergency personnel it can inhibit emergency response in the event of a crash or injury.
Volvo will notify owners, and dealers will correct the software, free of charge. The recall began December 26, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R39917.
View details Hide details
Service brakes, hydraulic: Pedals and linkages
2018-08-21
18V554000
Volvo Car USA LLC (Volvo) is recalling certain 2019 Volvo XC40 vehicles. The brake pedals may not have been correctly riveted, allowing the pedal to move out of position, possibly reducing braking performance.
Reduced braking performance can increase the risk of a crash.
Volvo has notified owners advising them to stop driving their vehicle. Cars will be inspected on-site or towed to dealers and the brake pedals will be replaced as necessary, free of charge. Volvo began contacting their owners on August 23, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R59899.