Chevrolet Recalls

Make selection is required

NHTSA safety recall results (534)

Recall information provided by National Highway Traffic Safety Administration

Power train

General Motors LLC (GM) is recalling certain model year 2013 and 2014 Chevrolet Cruze vehicles equipped with a 1.4L turbo engine, and manufactured between November 28, 2012, and March 7, 2014. On the affected vehicles, the right front half shaft may fracture and separate.

Recall consequence: If the half shaft fractures and separates while driving, the vehicle would lose power and coast to a stop. If a vehicle with a fractured half shaft is parked without the parking brake applied, the vehicle could move unexpectedly. Either condition increases the risk of a crash.
Recall action: GM will notify owners, and dealers will inspect and replace the right half shaft, as needed, free of charge. Parts for the remedy are not currently available. GM will send an interim letter to owners in May 2014. A second owner letter will be mailed when parts are available. Owners may contact Chevrolet at 1-866-694-6546. GM's number for this recall is 14079. This is an expansion of recall 13V-452. NOTE: Some vehicles subject to this recall were subject to the recall campaign initiated in 2013. Some of those vehicles were repaired using defective parts. Those owners will be advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles.

Air bags

General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.

Recall consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Recall action: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The manufacturer has not yet provided a notification schedule. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.

Air bags

General Motors LLC (GM) is recalling certain model year 2009-2014 Chevrolet Express and GMC Savana vans manufactured January 27, 2009, through March 7, 2014 with a gross vehicle weight rating of 10,000 pounds and less and equipped with front passenger air bags. In the affected vehicles, during a frontal impact below the air bag deployment threshold, if an unbelted front passenger's head hits the instrument panel above where the passenger air bag is located, the panel may not sufficiently absorb the impact. As such, these vehicles fail to meet the requirements of Federal Motor Vehicle Safety Standard number 201, "Occupant Protection in Interior Impact."

Recall consequence: In the event of a crash below the air bag deployment threshold, an unbelted front passenger seat occupant has an increased risk of injury.
Recall action: GM will notify owners. The manufacturer has not yet provided a remedy plan or notification schedule. Chevrolet owners may call 1-800-630-2438. GMC owners may call 1-866-996-9463. GM's number for this recall is 14082.

Component not known

General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, LaCrosse, Verano, and Enclave, and Chevrolet Impala, Malibu, Cruze, and Traverse, and GMC Acadia vehicles equipped with automatic transmissions. In the affected vehicles, the transmission shift cable adjuster may disengage from the transmission shift lever. As such, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect." They also fail to conform to FMVSS number 114, "Theft Protection and Rollaway Prevention."

Recall consequence: If a vehicle's shift cable disengages from the transmission shift lever, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the driver may be able to shift the lever to the "PARK" position, but the vehicle transmission may not be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Recall action: General Motors will notify owners, and dealers will inspect and replace any affected transmission shift cable adjusters, free of charge. The recall is expected to begin in late March 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Buick owners at 1-800-521-7300, and GMC owners at 1-800-462-8782. General Motors' number associated with this recall is 14048.

Electrical system

General Motors LLC (GM) announced on February 10, 2014 that they are recalling certain model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. Two weeks later, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Recall consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Recall action: GM will notify owners, and dealers will replace the ignition switch, free of charge. The recall began on March 10, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring.

Fuel system, diesel

General Motors LLC (GM) is recalling certain model year 2012-2013 Chevrolet Silverado HD and GMC Sierra HD vehicles, equipped with 6.6L diesel engines and dual fuel tanks. In the affected vehicles, the transfer pump which moves fuel from the rear tank to the front tank could malfunction and cause the fuel gauge to indicate an inaccurate reading.

Recall consequence: If the fuel gauge indicates an inaccurate reading it may result in the vehicle unexpectedly stalling, increasing the risk of a crash.
Recall action: General Motors will notify owners and dealers will inspect and replace the fuel transfer pump, as necessary, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet at 1-800-222-1020 and GMC at 1-800-462-8782. GM's number for this recall is 13420.

Visibility

General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Malibu vehicles manufactured June 12, 2013, through November 5, 2013. The heating, ventilation, and air conditioning (HVAC) control in these vehicles may intermittently become inoperable when the vehicle is started, preventing the windshield defroster from working. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 103, "Windshield Defrosting and Defogging Systems."

Recall consequence: The inability to turn on the windshield defroster may decrease the driver's visibility thereby increasing the risk of a crash.
Recall action: GM will notify owners, and dealers will update the electronic climate control module software, free of charge. The recall began during December 2013. Owners may contact GM at 1-800-521-7300. GM's recall campaign number is 13380.

Electrical system, seats

General Motors LLC (GM) is recalling certain model year 2013 Chevrolet Malibu vehicles manufactured October 25, 2011, through June 29, 2012 and equipped with the 8-way power adjustable front seat feature. The wiring harness for the power seat may contact the seat frame which may chafe the harness.

Recall consequence: If the harness is chaffed enough to expose the wires, a short circuit could occur, resulting unintended movement of the seat, the seat to become inoperative, sparking under the seat, flickering lights, smoke, or possibly a fire.
Recall action: GM will notify owners, and dealers will inspect the wire harness and repair and secure it as necessary, free of charge. The recall began during December 2013. Owners may contact GM at 1-800-521-7300. GM's recall campaign number is 13342.

Seats

General Motors (GM) is recalling certain model year 2014 Chevrolet Silverado and GMC Sierra 1500 vehicles manufactured August 1, 2013, through September 10, 2013, and equipped with manual reclining seatbacks. In the affected vehicles, either of the front seatbacks may have play. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 202a, "Head Restraints."

Recall consequence: If the vehicle is struck from behind, the head restraint may not properly protect occupants, increasing the risk of injury.
Recall action: GM has notified owners. Dealers will inspect the seatback recliner mechanisms and make adjustments, as needed, free of charge. Owners may contact Chevrolet at 1-800-222-1020 and GMC at 1-800-462-8782. GM's recall number is 13323.

Fuel system, gasoline

General Motors (GM) is recalling certain model year 2013 and 2014 Chevrolet Sonic vehicles manufactured August 2, 2013, through August 12, 2013. Due to insufficient welds, the front fuel tank strap bracket may separate from the vehicle.

Recall consequence: If the front fuel tank strap bracket separates, the increased load may lead to the failure of the other tank support. As a result, the fuel tank may come loose from the vehicle causing a fuel leak. A fuel leak, in the presence of an ignition source, may result in a fire.
Recall action: GM will notify owners, and dealers will inspect the front fuel tank strap bracket, and repair it as necessary, free of charge. The recall will begin in early November 2013. Owners may contact GM at 1-800-521-7300. GM's recall campaign number is 13296.