Chevrolet Recalls

Make selection is required

NHTSA safety recall results (534)

Recall information provided by National Highway Traffic Safety Administration

Power train, steering

General Motors (GM) is recalling certain model year 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT; Chevrolet Avalanche, Express, Silverado HD, Silverado LD, Suburban, and Tahoe; and GMC Savana, Sierra HD, Sierra LD, Yukon, and Yukon XL vehicles, manufactured between November 7, 2012, through December 18, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect", and FMVSS No. 114, "Theft Protection and Rollaway Prevention." The vehicles may have been built with a fractured park lock cable or a malformed steering column lock actuator gear in the lock module assembly.

Recall consequence: As a result, the vehicle may shift from Park with the ignition key removed or the ignition key in the OFF position. The vehicle may also shift out of Park without application of the brake pedal while the key is off. Either of these scenarios may cause the vehicle to roll away after the driver has exited the vehicle, resulting in a possible vehicle crash and/or injury.
Recall action: GM will notify owners, and dealers will inspect the affected vehicles and replace the steering column as necessary, free of charge. The recall began on January 21, 2013. Chevrolet owners may call 1-800-630-2438. Cadillac owners may call 1-866-982-2339. GMC owners may call 1-866-996-9463.

Latches/locks/linkages

General Motors is recalling certain model year 2010-2012 Chevrolet Colorado and GMC Canyon vehicles manufactured from November 9, 2009, through August 28, 2012, for failing to comply with the requirements of Federal Motor Vehicle Safety Standard No. 113, "Hood Latch System." The hood may be missing the secondary hood latch.

Recall consequence: If the primary hood latch is not engaged, the hood could open unexpectedly. During vehicle operation, this could obstruct the view of the driver and increase the risk of a crash.
Recall action: General Motors will notify owners and instruct them to inspect their vehicle for the presence of a secondary hood latch. Dealers will replace the hood on any affected vehicles, free of charge. The recall is expected to begin on January 17, 2013. Owners may contact Chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463.

Air bags

General Motors is recalling certain model year 2012 Buick Verano, Chevrolet Cruze, and Chevrolet Sonic vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.

Recall consequence: Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal airbag, that airbag will not deploy, increasing the driver's risk of injury.
Recall action: General Motors will notify owners, and dealers will replace the steering wheel airbag coil, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-521-7300.

Power train: Automatic transmission: Gear position indication (prndl)

General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.

Recall consequence: If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning.
Recall action: GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. The recall is expected to begin on, or about, November 12, 2012. Owners may contact General Motors at 1-800-521-7300.

Exterior lighting: Turn signal

General Motors LLC (GM) is recalling certain model year 2013 Chevrolet Sonic vehicles manufactured from May 29, 2012, through August 29, 2012. When a turn signal lamp fails to operate, the Body Control Module (BCM) in these vehicles does not detect this condition and will not indicate the condition to the driver. Thus, These vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, Reflective Devices, and Associated Equipment."

Recall consequence: If the driver is not aware that the turn signal is not functioning and does not have the light repaired, other drivers may not be alerted that the vehicle is turning, increasing the risk of a crash.
Recall action: GM will notify owners, and dealers will reprogram the BCM and the vehicle's key fobs, free of charge. The safety recall is expected to begin on October 3, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546.

Visibility: Windshield wiper/washer

General Motors LLC (GM) is recalling certain model year 2012 Chevrolet Sonic vehicles manufactured from May 5, 2011, through February 24, 2012. These vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 104, "Windshield Wiping and Washing Systems." The windshield wiper washer hose on these vehicles may separate from the washer fluid reservoir. If this occurs, washer fluid will not be available to the windshield.

Recall consequence: A lack of washer fluid could impede the driver's view, increasing the risk of a crash.
Recall action: GM will notify owners, and dealers will secure the windshield washer hose to prevent separation, free of charge. The safety recall is expected to begin on, or about, September 7, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546.

Parking brake

GENERAL MOTORS LLC (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET CAPTIVA SPORT PASSENGER VEHICLES MANUFACTURED FROM APRIL 26, 2012, THROUGH MAY 17, 2012. THESE VEHICLES FAIL TO CONFORM TO THE PARK BRAKE PERFORMANCE REQUIREMENTS FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "LIGHT VEHICLE BRAKE SYSTEMS." THE PARK BRAKE CABLE MAY NOT BE FULLY SEATED IN ITS CONNECTOR AND MAY SEPARATE FROM THE CONNECTOR. IF THIS OCCURS, THE PARK BRAKE WILL BECOME INOPERATIVE AND WILL NOT HOLD THE VEHICLE.

Recall consequence: IF THE VEHICLE IS ON AN UNEVEN SURFACE, THIS COULD RESULT IN UNINTENDED VEHICLE MOVEMENT AND A CRASH.
Recall action: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND ENSURE THAT THE PARK BRAKE CABLES ARE CONNECTED AND SECURE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON, OR ABOUT, JULY 18, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.

Fuel system, gasoline: Storage: Tank assembly: Mounting

GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 14, 2012. ATTACHMENT WELDS FOR THE FUEL TANK STRAP SECONDARY BRACKETS MAY HAVE BEEN OMITTED.

Recall consequence: THE FUEL TANK COULD COME LOOSE IN A CRASH, POSSIBLY ALLOWING FUEL TO LEAK FROM THE TANK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Recall action: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF THE VEHICLE IS MISSING WELDS, DEALERS WILL SECURE THE BRACKET ATTACHMENTS WITH FASTENERS. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON, OR ABOUT, JULY 11, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.

Engine and engine cooling

GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 31, 2012. SPILLED OR DRIPPING OIL (SUCH AS AFTER AN OIL CHANGE) MAY COLLECT IN THE ENGINE SHIELD (BELLYPAN) NEAR HOT ENGINE OR EXHAUST SYSTEM SURFACES. AS A RESULT, THE OIL AND THE ENGINE SHIELD MAY IGNITE AND BURN.

Recall consequence: EITHER CONDITION COULD RESULT IN AN ENGINE COMPARTMENT FIRE, POSSIBLY CAUSING INJURY OR DEATH.
Recall action: GM WILL NOTIFY OWNERS, AND DEALERS WILL MODIFY THE ENGINE SHIELD TO PREVENT FLUID FROM CONTACTING THE SHIELD. ALSO, ON VEHICLES WITH A MANUAL TRANSMISSION, DEALERS WILL APPLY A PROTECTIVE TAPE TO THE ELECTRONIC POWER STEERING WIRE HARNESS. REPAIRS WILL BE PERFORMED FREE OF CHARGE TO THE OWNER. THE SAFETY RECALL IS EXPECTED TO BEGIN ON, OR ABOUT, JULY 11, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.

Electrical system: software

GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2013 CHEVROLET MALIBU VEHICLES MANUFACTURED FROM OCTOBER 24, 2011, THROUGH MARCH 31, 2012. AFTER AN EVENT OF HARD BRAKING, THE SENSING AND DIAGNOSTIC MODULE (SDM) MAY RESET ITSELF.

Recall consequence: IF THIS OCCURS DURING AN AGGRESSIVE TURNING MANEUVER, AND THEN AFTERWARDS A POTENTIAL VEHICLE ROLLOVER EVENT IS SENSED, THE ROOF RAIL AIRBAG MAY UNINTENTIONALLY DEPLOY. ADDITIONALLY, THE AIR BAGS AND/OR SEATBELT PRETENSIONERS MAY NOT DEPLOY DURING A SEVERE CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Recall action: GM WILL NOTIFY OWNERS, AND DEALERS WILL REPROGRAM THE SDM. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 13, 2012.