2020 Kia Telluride Recalls

Make selection is required

NHTSA safety recall results (7)

Recall information provided by National Highway Traffic Safety Administration

Seats: Front assembly: Power adjust

Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The front power seat motor may overheat due to a stuck power seat slide knob or an improper recall 24V407 repair, which can result in a fire while parked or driving.

Recall consequence: A fire increases the risk of injury.
Recall action: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install an electronic fuse assembly, free of charge. Owner notification letters are expected to be mailed August 13, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC374. This recall replaces NHTSA recall number 24V407. Vehicles already repaired under the previous recall will need to have the new remedy completed. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning July 17, 2026.

Seats: Front assembly: Power adjust

Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The front power seat motor may overheat due to a stuck power seat slide knob, which can result in a fire while parked or driving.

Recall consequence: A fire increases the risk of injury.
Recall action: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a bracket for the power seat switch back covers and replace the seat slide knobs, free of charge. Owner notification letters were mailed July 30, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC316.

Power train: Driveline: Driveshaft

Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The intermediate shaft and right front driveshaft may not be fully engaged, which can result in vehicle roll away while in PARK.

Recall consequence: A vehicle roll away increases the risk of a crash or injury.
Recall action: Owners are advised to manually engage the emergency parking brake prior to exiting the vehicle until the recall remedy is performed. Dealers will update the electronic parking brake software and replace any damaged intermediate shafts as necessary, free of charge. Owner notification letters were mailed May 15, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC303.

Exterior lighting: Headlights

Kia America, Inc. (Kia) is recalling certain 2020 Telluride vehicles. The high beam headlights may fail.

Recall consequence: Inoperable high beam headlights may reduce visibility, increasing the risk of a crash.
Recall action: Dealers will inspect and repair or replace the high beam headlights, as necessary free of charge. Owner notification letters were mailed August 9, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC299.

Trailer hitches

Kia America, Inc. (Kia) is recalling certain 2020-2022 Telluride vehicles potentially equipped with a Genuine Kia 4-pin tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Recall consequence: A fire while parked or driving can increase the risk of injury.
Recall action: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse and a wiring harness extension. Dealers will also inspect and replace the tow hitch harness assembly, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed April 12, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC247.

Electrical system: Wiring

Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Recall consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.
Recall action: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.

Seat belts: Front

Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles. The seat belt assemblies in the front passenger, second, and/or third row seats may not tightly secure a child restraint system in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Recall consequence: If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash.
Recall action: Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies. The repair will also include replacing the driver's seat belt which has a non-U.S. specified label, with a U.S. specification seat belt. The repairs will be performed free of charge. The recall began August 30, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC181.